Textron PROWLER 500 2018 - General Maintenance; Default Chapter; Maintenance Schedule

33
General Maintenance
 NOTE: Proper maintenance of this
vehicle is important for optimum per-
formance. Follow the Maintenance
Schedule and all ensuing mainte-
nance instructions/information.
If, at any time, abnormal noises, vibra-
tions, or improper functioning of any
component of this vehicle is detected,
DO NOT OPERATE THE VEHICLE.
Take the vehicle to an authorized dealer
for inspection and adjustment or repair.
A repair shop or person of the owner's
choosing may maintain, replace, or repair
emission-control devices and systems.
If the owner/operator does not feel quali-
fied to perform any of these maintenance
procedures or checks, take the vehicle to
an authorized dealer for professional ser-
vice.
 NOTE: The following instructions
and information refer to specific
items in the maintenance and care of
this vehicle.
I = Inspect and clean, adjust, lubricate, replace as necessary, T = Tighten, R = Replace, C = Clean,
* = Dealer maintenance, **When using ACX All Weather synthetic oil, oil change interval can be increased
to every 1,000 miles or every year.
Maintenance Schedule
Item Page
Initial 100
miles
Every 100
miles
Every 300
miles
Every 500
miles
Battery 38 I I
* Engine nuts and bolts — I I
* Valve clearance — I I
Spark plug 41 I I
41 Replace every 4000 miles (6436 km) or 18 months
Liquid cooling system 34 I Inspect every time before operating
Gas Hoses 29 I Inspect every time before operating
Engine/transmission oil and filter 35 R R**
Air filter 41 I I
Gear lubricant
(front differential - rear drive)
35 R I I
V-belt 42 I I
Spark arrester/muffler 43 C
Tires/air pressure 43/17 I Inspect every time before operating
* Brake components 36 I Inspect every time before operating
Brake fluid 36 I Inspect every time before operating
Brake hoses 36 I Inspect every time before operating
* Steering — I Inspect every time before operating
* Suspension (Ball joint boots, drive
axle boots front and rear, tie rods,
differential and rear drive bellows)
— I Inspect every time before operating
* Chassis nuts and bolts — I T
Wheel lug nuts 43 T T
Frame/welds/racks — I I
Electrical connections — I I
Headlight/taillight-brakelight 44 I Inspect every time before operating
Air filter drains — I Inspect every time before operating
Accelerator pedal 24 I Inspect every time before operating
ROPS 47 Inspect every time before operating
Occupant side restraints 47 Inspect every time before operating
Wheel nuts 43 I I