Titan 404 - Safety Guidelines; Safety Alert Symbols and Signal Words; Operational Safety Decals

TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N
C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N
C
O
V
E
Y
O
R
S
TM
N
C
O
V
E
Y
O
R
S
TM
N
C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N
C
O
V
E
Y
O
R
S
TM
N
C
O
V
E
Y
O
R
S
TM
N
C
O
V
E
Y
O
R
S
TM
N
C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N
C
O
V
E
Y
O
R
S
TM
N C
O
V
E
Y
O
R
S
TM
N
C
O
V
E
Y
O
R
S
7/21
3
Safety
The Safety alert symbol is used with the signal words
DANGER, WARNING and CAUTION to alert you to safety messages.
They are used in safety decals on the unit and with proper operation and procedures in this manual. They
alert you to the existence and relative degree of hazards.
Understand the safety message. It contains important information about personal safety on or near the
conveyor.
POTENTIALLY HAZARDOUS SITUATION which if not avoided, could
result in death or serious injury.
POTENTIALLY HAZARDOUS SITUATION which if not avoided, may
result in minor or moderate injury. It may also be used to alert against
unsafe practices.
POTENTIALLY DESTRUCTIVE SITUATION which if not avoided, may
result in damage or reduce the longevity of the equipment.
Safety Decals
ALWAYS replace missing or damaged Safety Decals.
Operational Safety
CAUTION
!
DANGER
!
WARNING
!
Never run conveyor without
guards in place.
Keep Hands, feet, hair and
loose clothing away when
conveyor is running
ALWAYS lock out power before
servicing to avoid electrical
shock.
NEVER climb, sit, walk or ride
on conveyor
ALWAYS keep hands away from
conveyor while moving.
ALWAYS keep hair and loose
clothing away.
WARNING
KEEP AWAY
Moving equipment
can cause
severe injury
CHR 931005
DANGER
Climbing, sitting,
walking or riding on
conveyor at any time
will cause severe
injury or death
KEEP OFF
CHR930004
CHR930003
DANGER
!
Hazardous voltage
will cause severe
injury or death
LOCK OUT POWER
before servicing
WARNING
CHR951023
Rotating shaft can
cause severe injury
Keep hair and
loose clothing away
http://www.cemanet.org
!
CAUTION
KEEP HANDS AWAY
WHILE CONVEYOR IS RUNNING
WARNING
DRIVE CHAIN AND
SPROCKETS CAN
SEVER AND CRUSH
DO NOT RUN WITH
GUARD REMOVED
!
DANGER
KEEP HANDS,FEET, HAIR
AND LOOSE CLOTHING
A WA Y WHEN CONVEYOR
IS RUNNING
WARNING
TO PREVENT SERIOUS INJURY
NEVER START CONVEYOR UNTIL PERSONNEL ARE CLEAR
NEVER RUN CONVEYOR WITH GUARDS OFF
NEVER ATTEMPT MAINENANCE OR REP A IR WHILE CONVEYOR IS RUNNING
NEVER PLACE HANDS BY BELT PULLEYS OR SPROCKETS WHILE CONVEYOR
IS RUNNING
NEVER ALLOW PERSONNEL TO REST OR WALK ON CONVEYOR
NEVER WEAR LOOSE FITTING CLOTHING, GLOVES, RINGS, ECT., WHICH COULD GET
CAUGHT IN RUNNING CONVEYOR
IT IS THE EMPLOYER’S RESPONSIBILITY TO IMPLEMENT THE
ABOVE AND TO COMPLY WITH O.S.H.A. REQUIREMENTS
THIS WARNING LABEL MUST NOT BE REMOVED
WARNING
!
CHR930010
Exposed conveyors
and moving parts can
cause severe injury
LOCK OUT POWER
before removing
cover or servicing
ALWAYS lock out power
before servicing.
ALWAYS keep hands, feet, hair
& loose clothing away.
ALWAYS read and follow
warning labels.
DO NOT run conveyor with
guard o󰀨.
WARNING
DO NOT RUN
CONVEYOR WITH
GUARD OFF
Go to Table of Contents