Toro 07363 - Recommended Maintenance Schedule

34
Recommended Maintenance Schedule
Maintenance Service
Interval
Maintenance Procedure
After first 5 hours • Replace the engine oil and filter.
After first 10 hours
• Check cable adjustments
• Check pump drive belt tension
• Torque wheel lug nuts
• Replace transaxle filter
Every 50 hours
• Check the battery fluid level.
• Check the battery cable connections.
• Lubricate engine pre filter
• Replace engine oil and filter
Every 100 hours
• Lubricate all grease fittings
1
• Inspect condition and wear of tires
• Remove engine shrouds and clean fins
Every 200 hours
• Check cable adjustments
• Check pump drive belt tension
• Replace air cleaner filter
• Check engine RPM (idle and full throttle)
• Torque wheel lug nuts
Every 400 hours
• Check front wheel alignment
• Inspect service and parking brakes
• Inspect fuel lines
• Replace fuel filter
Every 800 hours
• Replace transaxle filter
• Change transaxle oil
• Clean transaxle strainer
• Replace spark plugs
• Pack front wheel bearings
Every 1200 hours or 2
years (whichever
occurs first)
• Replace all interlock switches
• Fuel tank–drain/flush
• Change brake fluid
1
immediately after every washing, regardless of the interval listed
Important Refer to your engine operator’s manual for additional maintenance procedures.