Trane Horizon OAKE360A - Horizon Dedicated Outdoor Air Unit Startup Form

Appendix
OAU-SVX01H-EN 73
Horizon™ Dedicated Outdoor Air Unit Startup Form
Date : __________________
Job Name
:_____________________________________________________________________
Address :_____________________________________________________________________
_____________________________________________________________________
Serial Number: ________________________________ Tag : __________________________
Start up contractor : _____________________________________________________________
Address :_____________________________________________________________________
_____________________________________________________________________
1 . Is there any visible shipping damage?
_____YES
_____NO
2. Is the unit level?
_____YES
_____NO
3. Are the unit clearances adequate for service and operation?
_____YES
_____NO
4. Do all access doors open freely and are the handles operational? _____YES _____NO
5 . Have all electrical connections been tested for tightness? _____YES _____NO
6 . Does the electrical service correspond to the unit nameplate? _____YES _____NO
7. On 208/230V units, has transformer tap been checked? _____YES _____NO
8. Have the damper assemblies been inspected? _____YES _____NO
9. Are the air filters installed with proper orientation? _____YES _____NO
10. Have condensate drain and p-trap been connected? _____YES _____NO
11. Have the crankcase heaters been on for 24 hrs. _____YES _____NO
Discharge temp Space Temp / Humidity
Supply Duct Pressure Transducer Return Duct / Space Pressure Transducer
Quantity
Orientatio
n Clean
#L1L2L3Amps
1
2
3
4
Factory supplied sensors installed
Filters
Location
Pre Startup Checklist
Size
Installing contractor should verify the following items.
Program Control
Non Heat Pump: Discharge Space Single Zone VAV Multi Zone VAV
Heat Pump: Discharge Space Single Zone VAV Multi Zone VAV
Compressors
Model
Serial
p