Troy-Bilt TB 2246 User Manual (English)

Questions and Answers:

D
davisgeorgeAug 13, 2025
How to troubleshoot Troy-Bilt Lawn Mower engine that fails to start?
- L
  Loretta DavisAug 13, 2025
  If your Troy-Bilt Lawn Mower engine won't start, here's what you can check: * Ensure the PTO/Blade Engage lever is disengaged (OFF). * Engage the parking brake. * Make sure the spark plug wire is connected. * Position the Throttle/Choke control lever to FAST. * Activate the choke by pushing the Throttle/Choke control lever into the Choke position. * Refuel with fresh gasoline (less than 30 days old). * Clear any blockage in the fuel line and replace the fuel filter. * Inspect the spark plug; clean, adjust the gap, or replace if needed. * If the engine is flooded, crank it with the Throttle/Choke control lever in the FAST position.
J
Jesus BraunAug 17, 2025
Why does my Troy-Bilt TB 2246 Lawn Mower engine run erratic?
- D
  Deborah RomeroAug 17, 2025
  If your Troy-Bilt Lawn Mower engine runs erratically, consider these potential causes and solutions: * Ensure the tractor isn't running with the choke activated; move the Throttle/Choke control lever out of the choke position. * Check and tighten the spark plug wires. * Inspect the fuel line for blockages and use clean, fresh gasoline; replace the fuel filter if needed. * Ensure the vent in the gas cap isn't plugged; clear it or replace the cap if damaged. * Drain the fuel tank and refill with clean, fresh gasoline to remove any water or dirt. * Replace the air cleaner paper element or clean the foam precleaner if the air cleaner is dirty.
J
Jason ArnoldAug 20, 2025
What to do if Troy-Bilt Lawn Mower engine overheats?
- C
  Christopher GarzaAug 20, 2025
  If your Troy-Bilt Lawn Mower engine is overheating, check these: * Make sure the engine oil level is at the proper amount and weight. * Clear any grass clippings and debris from around the engine’s cooling fins and blower housing to ensure proper airflow.
J
James MitchellAug 25, 2025
Why Troy-Bilt TB 2246 will not mulch grass?
- B
  Bethany FergusonAug 25, 2025
  If your Troy-Bilt Lawn Mower isn't mulching grass effectively, consider the following: * Ensure the engine speed is sufficient by placing the Throttle/Choke Control in the FAST position. * Avoid mulching when the grass is wet. * If the grass is excessively high, mow once at a high cutting height, then mow again at the desired height or make a narrower cutting swath. * Check if the blade is dull; sharpen or replace it.
J
Jacob Harrell MDAug 28, 2025
Why Troy-Bilt TB 2246 engine idles rough?
- D
  David NicholsonAug 28, 2025
  If your Troy-Bilt Lawn Mower engine idles roughly, examine these potential causes: * A fouled, faulty spark plug, or one with too wide a gap, can cause rough idling. Replace the spark plug and set the correct plug gap. * A dirty air cleaner can also lead to this issue. Replace the air cleaner element and/or clean the pre-cleaner.
O
osheltonAug 31, 2025
What causes excessive vibration in Troy-Bilt Lawn Mower?
- E
  Eric MartinezAug 31, 2025
  If you notice excessive vibration in your Troy-Bilt Lawn Mower, here are a couple of things to check: * Make sure the cutting blade is tightened and balanced on the spindle. * Inspect the cutting blade for damage or bending; replace it if necessary.
C
Carl HillSep 4, 2025
Why Troy-Bilt Lawn Mower produces uneven cut?
- E
  Eric CarrSep 5, 2025
  If your Troy-Bilt Lawn Mower is leaving an uneven cut, here's what to investigate: * Ensure the deck is leveled properly by performing a side-to-side deck adjustment. * Check if the blade is dull; sharpen or replace it. * Verify that the tire pressure is even in all four tires.
C
Corey WilliamsSep 8, 2025
What to do if Troy-Bilt TB 2246 Lawn Mower engine hesitates at high RPM?
- B
  Brittany ArnoldSep 8, 2025
  If your Troy-Bilt Lawn Mower engine hesitates at high RPM, it might be due to the spark plug gap being too close. Remove the spark plug and reset the gap.

Troy-Bilt TB 2246 Specifications

General

Brand	Troy-Bilt
Model	TB 2246
Category	Lawn Mower
Language	English

Summary

Safe Operation Practices

General Operation

Instructions for safe operation of the tractor, including handling foreign objects and bystanders.

Slope Operation

Guidelines for safe operation on slopes, including what to do and not to do.

Children

Safety precautions regarding children and operating the machine.

Towing

Safety precautions and recommendations for towing with the tractor.

Assembly & Set-Up

Tractor Set-Up

Procedures for preparing the tractor for use, including manual movement and shipping brace removal.

Connecting the Battery Cables

Step-by-step guide for connecting the tractor's battery cables correctly.

Setting the Deck Gauge Wheels

Instructions for adjusting deck gauge wheels for proper cutting height.

Adjusting the Seat

Procedure for adjusting the operator's seat position for comfort and safety.

Gas and Oil

Important information on fueling the tractor and checking engine oil level.

Controls and Features

Pedal Controls

Explanation of the tractor's foot pedals for speed and braking.

Throttle and Ignition Controls

Operation of the throttle, choke, and ignition switch for engine control.

Operator Information Display

Understanding the tractor's LCD for maintenance reminders and hours.

Seat Adjustment

Procedure for adjusting the operator's seat position.

Deck and PTO Controls

How to operate the deck lift lever and PTO/blade engage handle.

Parking Brake and Cruise Control

Functionality and operation of the parking brake and cruise control.

Operation

Safety Interlock Switches

Explanation of safety systems preventing operation under unsafe conditions.

Starting the Engine

Step-by-step guide to safely start the tractor's engine.

Stopping the Engine

Procedure for properly shutting down the tractor's engine.

Driving The Tractor

Guidelines for driving the tractor forward and controlling speed.

Reverse Caution Mode

How to operate the tractor in reverse with the blades engaged, with safety warnings.

Driving On Slopes

Specific instructions and warnings for operating the tractor on inclines.

Engaging the Parking Brake/ Setting the Cruise Control

How to set the parking brake and engage the cruise control feature.

Mowing

Tips and safety advice for effective and safe mowing operations.

Maintenance & Adjustments

Maintenance Schedule

A detailed schedule for regular maintenance tasks based on hours of use.

Changing the Engine Oil

Instructions for draining old oil and refilling with new oil.

Hydrostatic Transmission

Information on the sealed, maintenance-free hydrostatic transmission.

Battery

Guidelines for battery care, cleaning, and connection.

Cleaning the Tractor

Instructions for cleaning the tractor, including the deck wash system.

Lubrication

Details on lubricating front wheels, pivot points, and deck wheels.

Leveling the Deck (Front To Rear)

Procedure to adjust the cutting deck for proper front-to-rear leveling.

Leveling the Deck (Side to Side)

Procedure to adjust the cutting deck for proper side-to-side leveling.

Steering Adjustment

How to adjust drag links for proper steering alignment.

Service

Cutting Deck Removal

Step-by-step guide to safely remove the cutting deck from the tractor.

Changing the Deck Belt

Instructions for replacing the drive belt for the cutting deck.

Cutting Blades

Procedures for removing, sharpening, balancing, and replacing cutting blades.

Jump Starting

Instructions for safely jump-starting a discharged tractor battery.

Charging

Safety precautions and procedures for charging the tractor's battery.

Tires

Information on tire pressure and its effect on mowing.

Changing the Transmission Drive Belt

Guidance on replacing the tractor's transmission drive belt, recommending a service dealer.

Fuse

Locating and replacing the tractor's electrical system fuse.

Troubleshooting

Engine fails to start

Common causes and remedies for the engine not starting.

Engine runs erratic

Diagnosing and fixing issues causing the engine to run unevenly.

Engine overheats

Troubleshooting steps for an overheating engine.

Engine hesitates at high RPM

Solutions for when the engine struggles at high engine speeds.

Engine Idles rough

Causes and fixes for the engine running poorly at idle.

Excessive vibration

Identifying and resolving causes of excessive vibration during operation.

Mower will not mulch grass

Troubleshooting why the mower is not effectively mulching grass.

Uneven cut

Causes and solutions for achieving an even cut with the mower deck.

Replacement Parts

Spark Plug

Part number and description for the spark plug.

Air Filter Cartridge

Part number and description for the air filter cartridge.

Oil Filter

Part number and description for the oil filter.

Fuel Filter

Part number and description for the fuel filter.

Drive Belt (Mower Deck)

Part number and description for the mower deck drive belt.

Deck Spindle

Part number and description for the deck spindle.

Battery

Part number and description for the tractor battery.

Ignition Key

Part number and description for the ignition key.

Attachments & Accessories

Twin Bagger

Description of the compatible twin bagger attachment.

Mulch Kit

Description of the compatible mulch kit attachment.

Snow Blade Attachment

Description of the compatible snow blade attachment.

Tire Chains 20" x 8"

Description of compatible tire chains for added traction.

42 lb Rear Suit Case Weight Kit

Description of the compatible rear suit case weight kit.

Warranty

Emission Control Warranty

Details on emission control system warranty rights and obligations.

Manufacturer's Limited Warranty

Information on the limited warranty for the tractor and attachments.

Obtaining Service

Instructions on how to get warranty service and find authorized dealers.

State Law and Warranty

Explanation of how state laws affect warranty coverage and consumer rights.

Related product manuals

Troy-Bilt TB 370 XP

48 pages

Troy-Bilt TB 510 SERIES

Troy-Bilt TRU CUT 100

16 pages

Troy-Bilt TB 2246 User Manual

Table of Contents

Questions and Answers:

Troy-Bilt TB 2246 Specifications

Summary

Safe Operation Practices

General Operation

Slope Operation

Children

Towing

Assembly & Set-Up

Tractor Set-Up

Connecting the Battery Cables

Setting the Deck Gauge Wheels

Adjusting the Seat

Gas and Oil

Controls and Features

Pedal Controls

Throttle and Ignition Controls

Operator Information Display

Seat Adjustment

Deck and PTO Controls

Parking Brake and Cruise Control

Operation

Safety Interlock Switches

Starting the Engine

Stopping the Engine

Driving The Tractor

Reverse Caution Mode

Driving On Slopes

Engaging the Parking Brake/ Setting the Cruise Control

Mowing

Maintenance & Adjustments

Maintenance Schedule

Changing the Engine Oil

Hydrostatic Transmission

Battery

Cleaning the Tractor

Lubrication

Leveling the Deck (Front To Rear)

Leveling the Deck (Side to Side)

Steering Adjustment

Service

Cutting Deck Removal

Changing the Deck Belt

Cutting Blades

Jump Starting

Charging

Tires

Changing the Transmission Drive Belt

Fuse

Troubleshooting

Engine fails to start

Engine runs erratic

Engine overheats

Engine hesitates at high RPM

Engine Idles rough

Excessive vibration

Mower will not mulch grass

Uneven cut

Replacement Parts

Spark Plug

Air Filter Cartridge

Oil Filter

Fuel Filter

Drive Belt (Mower Deck)

Deck Spindle

Battery

Ignition Key

Attachments & Accessories

Twin Bagger

Mulch Kit

Snow Blade Attachment

Tire Chains 20" x 8"

42 lb Rear Suit Case Weight Kit

Warranty

Emission Control Warranty

Manufacturer's Limited Warranty

Obtaining Service

State Law and Warranty