TYM T503 User Manual

120 pages

To Next Page

TYM

OPERATOR’S MANUAL

FOR

TRACTORS

(T433/T503/T553)

#604-9, Namsan-dong, Changwon-city, Kyungnam, Korea ■

■■

■TEL:82-55-279-4379, FAX:82-55-279-4447 ■

■■

■www.tym.co.kr

Limited Warranty2
Warning Signs in this Manual5
Table of Contents6
Tractor Identification7
About this Manual8
Introduction & Description9
Description10
Owner Assistance12
Roll over Protective Structures (ROPS)13
ROPS (Roll over Protection Structures)13
- Damage of the ROPS14
- For Sliding Seat15
Safety Instructions, Do's & Don16
- Use of ROPS and Seat Belt17
- Precaution to Avoid Tipping17
- Park Tractor Safely17
- Fuel Handling18
- Danger of Rotating Shafts18
- Safety Lights and Devices18
- Safe Maintenance18
- Safe Service19
- Prevent Acid Burns19
- Avoid High-Pressure Fluids19
- Prevent Battery Explosions19
- Work in Ventilated Area20
- Tractor Runaway20
- Safety Starter Switch20
- Safe Operation21
- Safety Tips During Maintenance22
- Mounting and Demounting Implements23
- Precautions to Help Prevent Accidents24
- Do's and Don't's27
- Decals on the Dash Cover29
Safety Signs29
Decals on the Cabin30
Universal Symbols32
- Controls Description34
- Instrument and Switches34
- Warning Lights36
- Tractor Controls39
- Throttle Lever (Hand Throttle)39
- Foot Operated Accelerator40
- Clutch Cut-Off Alarm40
- Foot Operator Accelerator40
- Sub Gear Lever (Linear Shift Lever)41
- Shuttle Shift Lever41
- Main Gear Lever41
- To Avoid Personal Injury42
- Diff-Lock Pedal42
- Front Wheel Drive Lever43
- Driver's Seat Adjustment43
- Tilt Lever43
- Position Control44
- PTO Gear Selection Lever44
- Operating the Hydraulics44
- Lowering Speed Control Knob for the 3 Point Hitch45
- Draft Control Lever45
- Exterior Hydraulic Lever46
- Remote Hydraulic Control Valve Coupler Connecting and Disconnecting46
- Joystick Lever46
- Safety Implement for Joystick Lever47
- Operating the 3 Point Linkage (TPL)48
- Adjustment of the Lower Link49
- Telescopic Stabilizers Adjustment49
- Adjustment of the Top Link49
- Adjustment of the Lift Link on the Lower Link]50
- Mounting Implement50
- Driving the Tractor51
- Starting the Engine51
- Stopping the Engine51
- Warming up52
- Storing Engine in Operable Condition for 3 Months or more52
- Normal Braking and Parking53
- Tight Turns in the Field53
- Uphill Starts on a Steep Slope54
- Operation of the Diff Lock54
- Check During Riding54
- Fuel Gauge55
- Engine Cooling Water55
- Track Adjustment56
- Lubrication and Maintenance59
- Engine Oil Check60
- Transmission Oil Check60
- Engine Coolant Check60
- Pre-Start Checks60
- Fuel61
- Tyre Pressure61
- Brake Check62
- Clutch Check62
- Installing Loader62
- Detaching Loader62
- Maintenance and Adjustment Schedule63
- Periodical Check and Service Table63
- Filling Diagram and Capacity Table66
- Recommended Transmission Oil67
- Opening Method of Hood67
- Opening the Side Cover67
- Bleeding the Fuel System68
- Changing the Oils in the Tractor68
- Changing Engine Oil68
- Changing the Transmission Oil69
- Changing Oil in the Front Axle70
- Cleaning and Changing Filters70
- Engine Oil Filter70
- Fuel Filter71
- Changing the Coolant72
- Hydraulic Oil Filter and Engine Oil Filter Cartridge72
- Anti Freeze73
- Cleaning the Radiator73
- Greasing the Tractor74
- Gap Adjustment75
- Adjusting the Clutch75
- Adjusting the Brakes75
- Adjusting the Throttle Lever76
- Adjusting Toe-In76
- Fan Belt Adjustment77
- Battery Maintenance77
- Battery Charging77
- Alternator Inspection78
- Alternator and Fan Belts Inspect/Adjust/Replace78
- Air Conditioner Compressor Belt Adjustment79
- Servicing the Air Cleaner79
- Checking Hoses and Lines79
- Checking the Wiring Harness and Fuses80
- Replacing Fuses80
- Service Prior to Daily and Short Terms Storage80
- Long-Term Storage81
- Re-Use after Long Term Storage81
Cabin82
- Instrument and Related Parts83
- Working Lamps (Front and Rear)84
- Rearview Mirrors84
- Cab Ceiling84
- How to Control Cabin84
- Windscreen Washer Tank85
- Re-Circulation Inlets Fully Closed85
- Ventilation85
- Working Lamp Switch/Wiper Control Switch85
- Blower Control Switch86
- Temperature Control86
- Air Con. Switch86
- Circulation Diffuser86
- Heating System87
- Air Conditioning System89
- Compressor Belt Adjustment89
- Radio, CD Player90
- Cigarette Lighter90
- Cab Air Intake Filter90
- Roof Hatch90
- Checking the Air Conditioning System91
- Checking the Air Conditioning System Charge91
- Check the Refrigerant with Receive Drier Sight Glass91
- Diagnosing Malfunctions92
- Tracing Faults92
- To Check the Air Conditioning System with the Needle of High Low Gauge93
Specifications94
Fuel Saving Tips101
Fault Tracing103
- Wiring Diagram107
- Electric System Diagram109
- Roll-Bar Wiring Diagram110
- Cabin Wiring Diagram111
- Drawing for Fixing Position of the Fuse114
- Wiring Diagram of the Electric Instrument114
- Power Train Diagram115
Tractor History Card116
Service Record117
Daily Operating Log118
Part Replacement Record119

Questions and Answers:

Need help?

Do you have a question about the TYM T503 and is the answer not in the manual?

TYM T503 Specifications

General

Engine Type	Diesel
Engine Power	50 hp
Transmission	Synchro shuttle
PTO Power	42 hp
Hydraulic System	Open center
Weight	3, 373 lbs
Drive	4WD
Transmission Type	Synchro Shuttle
PTO Speed	540 rpm

Related product manuals

TYM T474

175 pages

TYM T503 User Manual

Table of Contents

Questions and Answers:

TYM T503 Specifications

Related product manuals