Unic URW295CR - Carrier Maintenance and Inspection; Carrier Inspection Before Operation

１．Inspection before operation
1.Check for remaining fuel quantity / Draining water
●When refuelin
g
,remove the ca
p
and never fail to
p
ut the strainer o
f
fuel tank in order to
p
revent water and dust from enterin
g
the tank.
Fuel tank ca
p
acity: 7 liters
●When drainin
g
fuel in order to trans
p
ort the crane and store it for lon
g
p
eriod of time,remove the strainer cu
p
in the fuel cock to extract it
.
2.Check for remaining fuel quantity / Draining water
★Re
p
lace en
g
ine oil after 25 hours of o
p
eration for initial re
p
lacement,
and after every 50-hour o
p
eraetion thereafter.
Check en
g
ine oil
q
uantity before startin
g
the en
g
ine with the crawler crane
p
arked
on a flat
g
round.
●Extract the oil level
g
au
g
e and wi
p
e it off with a
p
iece of clean ra
g
.
Insert the
g
au
g
e fully a
g
ain t
h
(Check the oil for contamination and viscosity at the same time.
)
where it is wetted with oil.
Oil
q
uantity to be filled u
p
: 1.2 litters
Frame
Truck roller
Function
Hydraulic oil tank
Engine
Fuel leakage
Remaining fuel quantity
Engine oil quantity/Filling up
Battery electrolytic solution
Unusual vibration,Noise
Loose bolt,Broken bolt
Loose bolt
Crack,Damage,Tension
Bend,Crack,Deformation
Loose nut,Oil leakage
Wheel sprocket
Rubber crawler
28．Mentenance And Inspection Of Carrier
Crawling lever Slack, Travel
Device Servicing item Device Servicing item
Oil leakage,Oil quantity,Filling
Interlock for
crane-crawl lever
Fuel tank cap
Fuel
cock
Filter
net
Straine
r cup
Oil level
g
au
g
e
Normal oil level
Check oil level everyday(Check it
without screwing-in the gauge.)
Upper limit
Lower limit
Drain plug
( 28 - 1 )