VENGEANCE Warrior 2003 - Maintenance Records

VENGEANCE MOTORCYCLES OWNERS MANUAL
- 67 -
Vengeance Motorcycles, Mira Loma, CA USA • 866-483-6432 • www.VengeanceMotorcycles.com
© 2003 Vengeance Performance Products, LLC All Rights Reserved • VOM 1st Edition Rev 2.3 06/03
500-MILE MAINTENANCE
 Change engine oil and oil filter and clean tappet screen.
 Change transmission lubricant and clean magnetic drain plug.
 Inspect air cleaner and service as required.
 Check and adjust primary belt.
 Check and adjust drive belt with motorcycle loaded (rider and any additional normal load).
 Check and adjust shift rod.
 Check and adjust clutch.
 Inspect brake pads and discs for wear.
 Inspect oil lines and brake system for leaks.
 Check brake fluid reservoir levels and condition. Add fluid as needed.
 Check and adjust front brake lever.
 Check and adjust rear brake pedal.
 Inspect and lubricate both forward control lever bearings.
 Lubricate front brake hand lever, throttle control cables, throttle, clutch control cable, & clutch hand lever.
 Check and adjust fuel enrichener operation.
 Inspect fuel valve, lines, and fittings for leaks.
 Check and adjust front and rear tire pressures and inspect tread and sidewall condition.
 Check rear fork pivot nut, if applicable.
 Check operation of all electrical equipment and switches.
 Clean battery connections.
 Inspect spark plugs and replace as needed (replacement at an additional charge).
 Check shock absorbers.
 Check stabilizer links and engine mounts.
 Check tightness of all fasteners except engine head bolts.
 Check and adjust engine idle speed.
 Perform diagnostic test on ignition module, note readings for discussion with customer.
 Confirm operation and performance with road test
Complete form above, attach copy of ignition diagnostic report, and forward to:
Vengeance Motorcycles Warranty Dept. 4501 Etiwanda Avenue Mira Loma, CA 91752 Fax (909) 681-2901
(Maintain a copy of this form for your records.)
NOTE:
The 500-mile maintenance service is MANDATORY and must be performed by an authorized Vengeance
Motorc
y
cles Dealer or Service Center to kee
p
y
our warrant
y
in effect
500-MILE MAINTENANCE SERVICE
DATE COMPLETED:__________ DEALER:______________________________
CUSTOMER:_______________________________________________________
MODEL:______________ YEAR:____________ MILEAGE:_________________
TECHNICIAN:______________________________________________________
TECH COMMENTS:_________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
ٱCopy of ignition diagnostic report attached