VENGEANCE Warrior 2003 - Page 75

VENGEANCE MOTORCYCLES OWNERS MANUAL
- 75 -
Vengeance Motorcycles, Mira Loma, CA USA • 866-483-6432 • www.VengeanceMotorcycles.com
© 2003 Vengeance Performance Products, LLC All Rights Reserved • VOM 1st Edition Rev 2.3 06/03
10,000-MILE MAINTENANCE
ٱ Change engine oil and oil filter and clean tappet screen.
ٱ Inspect transmission lubricant level and condition.
ٱ Inspect air cleaner and service as required.
ٱ Check and adjust primary belt as needed.
ٱ Check and adjust drive belt with motorcycle loaded (rider and any additional normal load).
ٱ Inspect brake pads and discs for wear.
ٱ Repack and adjust front and rear wheel bearings.
ٱ Inspect, repack, and adjust steering head bearing.
ٱ Change front fork oil.
ٱ Inspect oil lines and brake system for leaks.
ٱ Check brake fluid reservoir levels and condition. Add fluid as needed.
ٱ Check and adjust front brake lever.
ٱ Check and adjust rear brake pedal.
ٱ Check and adjust throttle and fuel enrichener operation.
ٱ Inspect fuel valve, lines, and fittings for leaks.
ٱ Check and adjust front and rear tire pressures and inspect tread and sidewall condition.
ٱ Check operation of all electrical equipment and switches.
ٱ Inspect and clean battery connections.
ٱ Inspect spark plugs and replace as needed (replacement at an additional charge).
ٱ Check stabilizer links and engine mounts.
ٱ Check and adjust engine idle speed.
ٱ Perform diagnostic test on ignition module, note readings for discussion with customer.
ٱ Confirm operation and performance with road test
Complete form above, attach copy of ignition diagnostic report, and forward to:
Vengeance Motorcycles Warranty Dept. 4501 Etiwanda Avenue Mira Loma, CA 91752 Fax (909) 681-2901
(Maintain a copy of this form for your records.)
NOTE:
Retain a co
py
of this service for
y
our records
,
or should
y
ou need future warrant
y
service.
10,000-MILE MAINTENANCE SERVICE
DATE COMPLETED:__________ DEALER:______________________________
CUSTOMER:_______________________________________________________
MODEL:______________ YEAR:____________ MILEAGE:_________________
TECHNICIAN:______________________________________________________
TECH COMMENTS:_________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
__________________________________________________________________
ٱCopy of ignition diagnostic report attached