Home
Viessmann
Boiler
B2HAH13
Viessmann B2HAH13 Installation Instructions For Contractors
4
of 1
of 1 rating
112 pages
Give review
Manual
Specs
To Next Page
To Next Page
Loading...
Installation and service instructions
for contractors
VIESMANN
Vitodens 222-F
T
ype B2SB
, 1.9 to 26.0 kW
Gas condensing storage combi boiler
Natural gas and LPG version
For applicability
, see the last page
VITODENS 222-F
5778 729 GB
9/2016
Please keep safe.
2
Table of Contents
Index Index
4
Default Chapter
4
Table of Contents
4
1 Information Disposal of Packaging
6
Symbols
6
Intended Use
7
Product Information
7
Vitodens 222-F, Type B2SB
7
2 Preparing for Installation Preparing for Boiler Installation
8
Safety Assembly to DIN 1988 and en 806 on the Cold Water Connection
10
3 Installing the Boiler Removing the Front Panels
11
Siting and Levelling the Boiler
12
Connections on the Heating Water and DHW Side
13
Connection on the DHW Side
13
Flue Gas Connection
13
Gas Connection
14
Opening the Control Unit Enclosure
15
Electrical Connections
15
Routing the Power Cable
16
External Demand Via 0 - 10 V Input
18
External Demand Via Switching Contact
18
Outside Temperature Sensor
18
External Blocking Via Switching Contact
19
Power Supply for Accessories at Plug Lh (230 V ~)
20
Power Supply Fö
21
Routing Connecting Cables
21
Closing the Control Unit Enclosure
22
Fitting the Front Panels
23
Commissioning, Inspection, Maintenance Steps - Commissioning, Inspection and Maintenance
24
4 Commissioning, Inspec-Steps - Commissioning, Inspection and Maintenance
24
Removing the Front Panels
25
Filling the Heating System
25
Filling the DHW Cylinder on the DHW Side
26
Filling the Trap with Water
27
Venting the Boiler
27
Information on Automatic Testing of the Flue Gas Temperature Sensor
28
Switching on the Power Supply and the ON/OFF Switch
28
Venting the Heating System
28
Checking the Gas Type
29
Gas Type Conversion (Only for Operation with LPG)
29
Checking the Static Pressure and Supply Pressure
29
Function Sequence and Possible Faults
31
Setting the Heating Output
32
Tightness Test on Balanced Flue System (Annular Gap Test)
32
Removing the Burner
33
Checking the Burner Gasket and Burner Gauze Assembly
34
Checking and Adjusting the Ignition and Ionisation Electrodes
35
Checking the Condensate Drain and Cleaning the Trap
35
Cleaning the Heating Surfaces
35
Checking the Anode Connection
37
Checking the Neutralising System (if Installed)
37
Installing the Burner
37
Checking the Anode Earth Current with an Anode Tester
38
Draining the Boiler on the DHW Side
39
Checking and Replacing the Magnesium Anode (if Required)
40
Cleaning the DHW Cylinder
40
Reassembling and Filling the DHW Cylinder
41
Checking the Expansion Vessel and System Pressure
41
Checking the Pre-Charge Pressure and the DHW Expansion Vessel (if Installed)
42
Checking the Safety Valve Function
42
Checking the Firm Seating of Electrical Connections
42
Checking All Gas Equipment for Tightness at Operating Pressure
43
Checking the External LPG Safety Valve (if Installed) 35. Checking the Combustion Quality
43
Matching the Control Unit to the Heating System
44
Scanning and Resetting the "Service" Display
44
Fitting the Front Panels
45
Instructing the System User
45
General"/Group 1
46
5 Codes Coding Level 1
46
Calling up Coding Level 1
46
Boiler"/Group 2
47
Dhw"/Group 3
48
Heating Circuit
48
Coding Level 2
49
Calling up Coding Level 2
49
General"/Group 1
49
Boiler"/Group 2
53
Dhw"/Group 3
55
Heating Circuit
56
Scans Calling up the Service Menu
57
Exiting the Service Menu
57
Diagnosis
57
Operating Data
57
Brief Scan
57
Checking Outputs (Actuator Test)
59
6 Diagnosis and Service Service Menu
57
7 Troubleshooting Fault Display
60
Constant Temperature Control Unit
60
Fault Codes
60
Maintenance
67
Putting the Control Unit into the Service Position
67
Draining the Boiler on the Heating Water Side
68
Checking the Outside Temperature Sensor
69
Checking the Boiler Water Temperature Sensor, Cylinder Temperature Sensor or Flow Temperature Sensor of Low Loss Header
70
Checking the Flue Gas Temperature Sensor
71
Checking the Temperature Limiter
71
Checking the Fuse/Mcb
72
8 Parts Lists Overview of Assemblies
73
Ordering Parts
73
Casing
74
Heat Cell
76
Matrix Cylinder Burner
78
Hydraulics
80
Hydraulic Block
84
DHW Cylinder
86
Control Unit
88
Miscellaneous
90
Ordering Individual Parts for Accessories
92
9 Function Description Constant Temperature Control Unit
93
DHW Heating with Gas Condensing Boiler
93
DHW Heating with Gas Condensing Combi Boiler
93
Heating Mode
93
Internal Extensions (Accessories)
94
Internal H1 Extension
94
Internal H2 Extension
95
External Extensions (Accessories)
96
AM1 Extension
96
EA1 Extension
97
Control Functions
98
External Operating Program Changeover
98
External Blocking
99
External Demand
99
Venting Program
99
Fill Program
100
Electronic Combustion Control Unit
100
10 Connection and Wiring Dia-Connection and Wiring Diagram - Internal Connections
101
Grams Connection and Wiring Diagram - External Connections
102
11 Commissioning/Service
103
12 Specification
104
13 Certificates Declaration of Conformity
106
Manufacturer's Declaration
106
Manufacturer's Certificate According to the 1St Bimschv [Germany]
107
14 Keyword Index
108
Other manuals for Viessmann B2HAH13
Operating Instructions For The System User
72 pages
Troubleshooting
41 pages
Technical Guide
112 pages
Service Instructions
108 pages
Installation Instructions
60 pages
Domestic Product Guide
56 pages
Operating Instructions
44 pages
Technical Data Manual
36 pages
Installation And Service Instructions
172 pages
Replacement Instructions
56 pages
Installation And Service Instructions For Contractors
156 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Viessmann B2HAH13 and is the answer not in the manual?
Ask a question
Viessmann B2HAH13 Specifications
General
Model
B2HAH13
Category
Boiler
Fuel Type
Natural Gas / Propane
Efficiency
95%
AFUE
95%
Warranty
10 years
Gas Connection Size
3/4 inch
Water Connection Size
1 inch
Related product manuals
Viessmann Vitodens 200-W B2HA 80
60 pages
Vitodens 200-W B2HA 100
60 pages
VITODENS 200-W B2HA 112
195 pages
VITODENS 200-W B2HA 150
195 pages
Vitodens 200-W B2HA 399
195 pages
Vitodens 200-W B2HA 530
195 pages
VITODENS 200-W Type B2HA
104 pages
Viessmann B2HF
136 pages
Viessmann Vitodens 200-W B2HE
128 pages
Viessmann VITODENS 200-W B2HE 85
48 pages
Viessmann Vitodens 222-W B2LB
19 pages
Viessmann VITODENS 222-F B2TA 35
108 pages