2.4L 5-CYL VIN [55]
1995 Volvo 850
1995-96 ENGINES
Volvo - 2.4L 5-Cylinder
850
* PLEASE READ THIS FIRST *
NOTE: For repair procedures not covered in this article, see
ENGINE OVERHAUL - GENERAL INFORMATION article in GENERAL
INFORMATION section. Repair information for this engine is
not available at time of publication.
ENGINE IDENTIFICATION
Engine may be identified by using Vehicle Identification
Number (VIN) stamped on a metal pad, located near lower left corner of
windshield. The sixth and seventh character identifies engine model.
Engine identification number, located on left side of
cylinder block below cylinder head, may be required when ordering
replacement parts.
ENGINE IDENTIFICATION CODES TABLE
Engine Code
2.4L (Non-Turbo) ...................................... 55
ADJUSTMENTS
VALVE CLEARANCE ADJUSTMENT
Engine is equipped with hydraulic lifters. No valve
adjustment is necessary.
REMOVAL & INSTALLATION
NOTE: For reassembly reference, label all electrical connectors,
vacuum hoses and fuel lines before removal. Also place
mating marks on other major assemblies before removal. Hood
removal is not necessary, as hood opens to horizontal
position. Removal and installation information for
turbocharger is not available at time of publication.
FUEL PRESSURE RELEASE
Fuel Pump Pressure Release
Before disconnecting any lines, cover fuel line connector
with shop towel to absorb any fuel left in line. With ignition key
removed from ignition switch, reconnect relay.
ENGINE
Removal
1) Remove expansion tank cap. Raise and support vehicle.
Remove splash guard and air baffle under engine. Drain all coolant by
To Next Page
Need help?
Torque Specifications
