Wylie Power Sprayer Series User Manual (English)

Questions and Answers:

C
cheryl75Aug 4, 2025
What to do if Wylie Paint Sprayer pump output is very low?
- M
  meganknightAug 4, 2025
  If the Wylie Paint Sprayer pump output is very low or erratic, several issues could be the cause. First, make sure the spray tank isn't low, causing air to enter the pump; if so, fill the tank and bleed air by removing the top plug. Also, ensure the tank ball valve is fully open and the strainer isn't plugged; clean the strainer screen if needed. Check for a collapsed suction hose and replace it if necessary. Inspect the suction system for air leaks by tightening fittings and looking for cracks, applying thread sealant to pipe threads. Ensure the control bypass is disengaged by closing the blue bypass lever. Adjust the pressure control knob by screwing it in to increase pressure. If these steps don't resolve the issue, the pump may be malfunctioning.
S
Sara TranAug 9, 2025
How to fix no output or insufficient pressure at spray tip(s) in Wylie Power Sprayer?
- L
  Lisa TaylorAug 9, 2025
  If you're experiencing no output or insufficient pressure at the spray tips of your Wylie Paint Sprayer, there are several potential causes. You may have an air leak in the suction side of the system. Another potential cause is a malfunctioning control valve. Furthermore, ensure the control bypass is not engaged by verifying that the blue bypass lever is closed, and check that the pressure hose ball valve is open. Lastly, the spray tips may not be the proper size, so replace them with the correct ones.
J
John TurnerAug 16, 2025
Why Wylie Power Sprayer engine will not operate?
- C
  Cody ScottAug 16, 2025
  If the engine of your Wylie Paint Sprayer won't operate, there are a few potential reasons. First, check if the engine is out of gasoline and add gasoline to the fuel tank if needed. If the fuel tank has enough gasoline, the engine controls may not be set properly. Finally, the engine itself may be malfunctioning.

Wylie Power Sprayer Series Specifications

General

Brand	Wylie
Model	Power Sprayer Series
Category	Paint Sprayer
Language	English

Summary

Warranty Information

A Message To The Owner And Operator

General advice for operators to ensure efficient and safe operation of the equipment.

Limited Warranty

Details the warranty coverage, duration, and limitations for Wylie manufactured products.

Disclaimer of Warranty

Outlines conditions for warranty coverage and disclaims warranties for specific uses and chemicals.

Owner Registration

Safety Issues

Safety Precautions

Alerts users to hazards and defines danger, warning, and caution terms used in the manual.

Before Use

Provides critical safety checks and precautions to take before operating the sprayer.

During Use

Lists essential safety guidelines to follow while the sprayer is in operation.

Safety Operational Phases

After Use Safety

Details post-operation inspection and maintenance safety checks for the sprayer.

General Safety Reminders

General safety reminders applicable at all times when operating or near the equipment.

Operator's Instructions

Specific instructions for safe operation of the sprayer, focusing on movement and handling.

Reporting Safety Defects

Instructions on how to report safety defects to NHTSA and Wylie Manufacturing.

Safety Decals & Placement

Introduction

Power Sprayer Skid Specifications

Lists technical specifications for Wylie Power Sprayer skid models.

Power Sprayer Trailer Specifications

Lists technical specifications for Wylie Power Sprayer trailer models.

Inspection & Setup

Mounting Skid on Truck/Pickup

Instructions on how to safely mount a sprayer skid onto a truck or pickup.

Attaching Trailer to Vehicle

Steps for securely attaching a Wylie trailer to a tow vehicle.

Trailer & Hose Reel Setup

Trailer Hitch Details

Explains the trailer hitch mechanism, including breakaway system and adjustment.

Electric Hose Reel Setup

Information on setting up and powering the electric hose reel.

Motor, Pump, and Initial Startup

Inspecting Motor and Pump

Guidance on checking the motor and pump before initial startup.

Initial Startup Procedure

Steps for initial startup of the sprayer, including adding water and checking for leaks.

Operation

Adding Chemical Safely

Safety precautions and procedures for adding chemicals to the sprayer tank.

Swivel Hose Reel Usage

Instructions on using and locking the 180° swivel hose reel.

CDS/John Blue Pump Operation

Specific instructions for operating the CDS/John Blue diaphragm pump.

Pump Controls and Engine Start

Bypass Valve Operation

Explains how to use the bypass valve for the pump.

Honda Engine Start Switch

Describes the start switch for Honda engines used in the sprayers.

Agitator and Pressure Valve Adjustment

Instructions on opening agitator valve and adjusting pressure.

Changing Pump Mode

How to switch the pump from bypass to pressure mode.

Pressure Adjustment and Pump Styles

Adjusting Sprayer Pressure

Guidance on adjusting the sprayer's operating pressure.

Operating Other Pump Styles

Information on operating roller and centrifugal pumps.

Operating The Trigger Gun

How to operate the trigger gun for spray pattern adjustment.

Twin Tank Valve Management

Specific instructions for managing valves in twin-tank sprayers.

Boom Attachments and Procedures

Walking Boom Operation

Details on the walking boom attachment for even lawn applications.

Flat Fold Boom Operation

Instructions for mounting and using the flat fold boom attachment.

Fresh Water Tank Usage

Information about the fresh water tank and its uses.

End of Day Procedure

Steps for flushing and cleaning the sprayer at the end of the day.

End of Season Procedure

Guidelines for winterizing the sprayer to prevent freeze damage.

Maintenance

Strainer Maintenance

How to clean the strainer to maintain optimal pump pressure.

Engine/Pump Maintenance

Directs users to manufacturer manuals for engine and pump maintenance.

Spray Tank Maintenance

Advice on cleaning and maintaining the spray tank to prevent algae growth.

Troubleshooting Guidelines

Engine Will Not Operate

Lists causes and solutions for the engine failing to start or run.

Pump Will Not Operate

Identifies reasons why the pump may not be functioning and provides solutions.

Pump Output Issues

Troubleshooting steps for low, erratic pump output, or no solution movement.

Low Spray Pressure

Solutions for issues with no spray output or low pressure at the nozzle.

Hypro Trigger Gun Pattern

Correcting spray pattern issues with the Hypro trigger gun.

Tire Safety Information

TIRE SAFETY INFORMATION Overview

Overview of tire safety information requirements and content.

Trailer Load Limit Determination

How to determine the correct load limits for trailers.

Trailer and Tow Vehicle Load Limits

Trailer Loading Limits (Under 10,000 lbs)

Loading information for trailers under 10,000 lbs GVWR.

Trailer Loading Limits (Over 10,000 lbs)

Loading information for trailers over 10,000 lbs GVWR.

Tow Vehicle Load Limit Determination

How to determine load limits for the tow vehicle.

Glossary of Tire Terminology

Definitions of common tire-related terms.

Tire Markings and Ratings

Passenger Vehicle Tire Markings

Explanation of markings found on passenger vehicle tire sidewalls.

Speed Rating and U.S. DOT Identification

Details on tire speed ratings and DOT identification numbers.

UTQGS Information

Explanation of Uniform Tire Quality Grading System ratings (Treadwear, Traction, Temperature).

Light Truck Tire Markings

Explanation of markings specific to light truck and trailer tires.

TIRE SAFETY TIPS

Practical advice for preventing tire damage and ensuring safety.

Notes

Related product manuals

Wylie Defender 3 Pt Sprayer

34 pages

Wylie Power Sprayer Series User Manual

Table of Contents