XtremepowerUS 62FT - Safety and Operation Instructions; Child Safety; Component Separation Hazard; Avoiding Component Separation

This is the safety-alert symbol. When you see this symbol on your equipment or in this manual, look for one
of the following signal words and be alert to the potential for personal injury or death.
WARNING
Warns about hazards that could cause serious personal injury or, death, and or major property
damage and if ignored presents a potential hazard.
CAUTION
Warns about hazards that will or can cause minor or moderate personal injury and/or property
damage and if ignored presents a potential hazard. It can also make consumers aware of actions that are
unpredictable and unsafe.
The NOTICE label indicates special instructions that are important but not related to hazards.
READ, UNDERSTAND, AND FOLLOW ALL SAFETY AND OPERATION INSTRUCTIONS.
FAILURE TO FOLLOW SAFETY AND OPERATION INSTRUCTIONS CAN RESULT IN SEVERE
PERSONAL INJURY OR DEATH.
CAUTION To reduce risk of injury, do not permit children to use or climb on this product. Closely
supervise children at all times. The ANSI/NSPI-4 Standard (above-ground and on-ground pools)
DGYLVHVWKDWFRPSRQHQWVVXFKDVWKH¿OWUDWLRQV\VWHPSXPSVDQGKHDWHUVEHSRVLWLRQHGWRSUHYHQW
their being used as a means of access to the pool by young children.
WARNING
COMPONENT SEPARATION HAZARD
Pool and spa water circulation systems operate under hazardous pressure during start up, normal
operation, and possibly after pump shut off. Pressure in system can cause explosive component
VHSDUDWLRQRIWKHXSSHU¿OWHUERG\LIVDIHW\DQGRSHUDWLRQLQVWUXFWLRQVDUHQRWIROORZHG6HYHUHSHUVRQDO
injury or death can result.
7KLVSURGXFWVKRXOGEHLQVWDOOHGDQGVHUYLFHGRQO\E\DTXDOL¿HGSRROSURIHVVLRQDO
TO AVOID COMPONENT SEPARATION
)ROORZDOOVDIHW\DQGRSHUDWLRQLQVWUXFWLRQV
'RQRWRSHUDWHZDWHUFLUFXODWLRQV\VWHPLIDV\VWHPFRPSRQHQWLVDVVHPEOHGLPSURSHUO\GDPDJHG
missing, or not a genuine component.
%HIRUHSHUIRUPLQJPDLQWHQDQFHRQWKHZDWHUFLUFXODWLRQV\VWHPYHULI\DOOV\VWHPDQGSXPSFRQWUROV
DUHLQ2))SRVLWLRQDQG¿OWHUPDQXDODLUUHOLHIYDOYHLVLQWKH23(1SRVLWLRQ
8VH21/<JHQXLQHFRPSRQHQWV3OHDVHXVHRULJLQDOFRPSRQHQWVRWKHUZLVHPD\IDLOLQXVHDQG
cause explosive separation.
1HYHUUHO\RQKDQGWLJKWHQLQJWKHFODPSQXWWRWKHFODPSEROW8VLQJDô´VRFNHWRQDWRUTXHZUHQFK
torque clamp nut and clamp bolt to 150 inch-lbs.
%HIRUHVWDUWLQJV\VWHPSXPSLQVXUH¿OWHUPDQXDODLUUHOLHIYDOYHERG\LVLQ/2&.SRVLWLRQLQ¿OWHU
upper body.
%HIRUHVWDUWLQJWKHV\VWHPSXPSYHULI\WKDWDOOV\VWHPYDOYHVDUHVHWLQDSRVLWLRQWRDOORZZDWHUIURP
WKH¿OWHUWRUHWXUQEDFNWRWKHSRRO
%HIRUHVWDUWLQJWKHV\VWHPSXPSWKHPDQXDODLUUHOLHIYDOYHPXVWEHLQWKH23(1SRVLWLRQ
:KHQVWDUWLQJSXPSGRQRWVWDQGRYHURUQHDU¿OWHU
,IZDWHUOHDNDJHDSSHDUVLQWKHDUHDRIWKH¿OWHUWDQNFODPSLPPHGLDWHO\WXUQRIIDOOV\VWHPFLUFXODWLRQ
SXPSVDQGHOHFWULFDOSRZHU'RQRWUHWXUQWRWKH¿OWHUXQWLODOOZDWHUÀRZKDVVWRSSHG5HDVVHPEOH
the clamp system per the instructions in this owner’s manual to stop the leak.
5HWXUQWR¿OWHUWRFORVHPDQXDODLUUHOLHIYDOYHRQO\ZKHQDVWHDG\VWUHDPRIZDWHU1RWDLURUDLUDQG
water mix) is discharged from the manual air relief valve.
'RQRWFKDQJH¿OWHUFRQWUROYDOYHSRVLWLRQZKLOHV\VWHPSXPSLVUXQQLQJ
W
ARNING EXCESS PRESSURE HAZARD
3UHVVXUHWHVWLQJRIWKHSXPSDQG¿OWHUV\VWHPLQH[FHVVRIWKH36,FDQFDXVHH[SORVLYHVHSDUDWLRQ
of the components. Component separation can result in severe personal injury or death.