Yamaha F9.9J - Page 87

To Next Page

To Previous Page

U6DR70E0.book Page 81 Thursday, December 6, 2012 9:14 AM

Main Page

Table of Contents4
Safety Information7
Outboard Motor Safety7
Propeller7
Rotating Parts7
Hot Parts7
Electric Shock7
Power Tilt7
Engine Shut-Off Cord (Lanyard)7
Gasoline7
Gasoline Exposure and Spills8
Carbon Monoxide8
Modifications8
Boating Safety8
Alcohol and Drugs8
Personal Flotation Devices (Pfds)8
People in the Water8
Passengers8
Overloading8
Avoid Collisions9
Weather9
Passenger Training9
Boating Safety Publications9
Laws and Regulations9
General Information10
Identification Numbers Record10
Outboard Motor Serial Number10
Key Number10
EC Declaration of Conformity (Doc)10
CE Marking11
Read Manuals and Labels12
Warning Labels12
Specifications and Requirements16
Specifications16
Installation Requirements18
Boat Horsepower Rating18
Mounting Outboard Motor18
Remote Control Requirements18
Battery Requirements19
Battery Specifications19
Mounting Battery19
Propeller Selection19
Start-In-Gear Protection20
Engine Oil Requirements20
Fuel Requirements20
Gasoline20
Muddy or Acidic Water21
Anti-Fouling Paint21
Outboard Motor Disposal Requirements21
Emergency Equipment21
Components22
Components Diagram22
Fuel Tank24
Fuel Joint25
Fuel Gauge25
Fuel Tank Cap25
Air Vent Screw25
Remote Control Box25
Remote Control Lever25
Neutral Interlock Trigger26
Neutral Throttle Lever26
Choke Switch26
Tiller Handle26
Gear Shift Lever26
Throttle Grip27
Throttle Indicator27
Throttle Friction Adjuster27
Engine Shut-Off Cord (Lanyard) and Clip28
Engine Stop Button28
Choke Knob for Pull Type29
Manual Starter Handle29
Main Switch29
Power Tilt Switch29
Steering Friction Adjuster30
Trim Rod (Tilt Pin)30
Tilt Lock Mechanism31
Tilt Support Knob31
Tilt Support Bar31
Power Tilt Unit31
Cowling Lock Lever32
Flushing Device32
Alert Indicator32
Instruments and Indicators33
Indicators33
Low Oil Pressure-Alert Indicator33
Engine Control System34
Alert System34
Low Oil Pressure Alert34
Installation35
Mounting the Outboard Motor35
Clamping the Outboard Motor37
Operation38
First-Time Operation38
Fill Engine Oil38
Breaking in Engine38
Getting to Know Your Boat38
Checks before Starting Engine38
Fuel Level38
Removing Top Cowling39
Fuel System39
Controls39
Engine Shut-Off Cord (Lanyard)39
Engine Oil40
Outboard Motor40
Flushing Device40
Install Top Cowling40
Checking Power Tilt System41
Battery42
Filling Fuel42
Operating Engine43
Sending Fuel (Portable Tank)43
Starting Engine44
Checks after Starting Engine48
Cooling Water48
Warming up Engine49
Manual Start and Electric Start Models49
Checks after Engine Warm up49
Shifting49
Stop Switches49
Stopping Boat51
Stopping Engine51
Procedure51
Procedure52
Trimming Outboard Motor52
Adjusting Trim Angle for Manual Tilt Models52
Adjusting Trim Angle (Power Tilt Models)53
Adjusting Boat Trim53
Tilting up and down54
Procedure for Tilting up (Manual Tilt Models)55
Procedure for Tilting up (Power Tilt Models)56
Procedure for Tilting down (Manual Tilt Models)56
Procedure for Tilting down (Power Tilt Models)57
Shallow Water57
Cruising in Shallow Water (Manual Tilt Models)57
Power Tilt Models59
Cruising in Other Conditions59
Maintenance60
Transporting and Storing Outboard Motor60
Dismounting the Outboard Motor60
Storing Outboard Motor62
Procedure62
Lubrication63
Flushing Power Unit64
Cleaning the Outboard Motor64
Checking Painted Surface of Outboard Motor65
Periodic Maintenance65
Replacement Parts65
Severe Operating Conditions65
Maintenance Chart 166
Maintenance Chart 268
Greasing69
Cleaning and Adjusting Spark Plug70
Checking Fuel Filter71
Inspecting Idle Speed71
Changing Engine Oil71
Inspecting Wiring and Connectors73
Checking Propeller73
Removing Propeller74
Installing Propeller75
Changing Gear Oil75
Cleaning Fuel Tank77
Inspecting and Replacing Anode(S)78
Checking Battery (for Electric Start Models)78
Connecting the Battery79
Disconnecting the Battery79
Trouble Recovery80
Troubleshooting80
Temporary Action in Emergency83
Impact Damage83
Replacing Fuse83
Power Tilt will Not Operate84
Starter will Not Operate84
Emergency Starting Engine85
Engine Fails to Operate86
Emergency Engine Operation86
Treatment of Submerged Motor86

Related product manuals

Yamaha JET DRIVE F90(65)

36 pages

Yamaha F9.9J - Page 87

Table of Contents

Related product manuals