EasyManua.ls Logo

Yazoo/Kees ZKW42170 - User Manual

Yazoo/Kees ZKW42170
19 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
Professional Quality Lawn Care Equipment
since 1945
Thank you for buying a YAZOO/KEES ZT Max! Before operating your new mower, read,
understand and follow the important safety instructions and the other instructions con-
tained in this manual. Lawnmowers and all power equipment, can be potentially danger-
ous if used improperly. SAFETY REQUIRES GOOD JUDGEMENT, CAREFUL USE IN
ACCORDANCE WITH INSTRUCTIONS AND COMMON SENSE.
Operator’s Manual for
MODELS: ZKW42170
ZKW48170
MANUAL 103337 REV.04(12/13/00)

Table of Contents

Questions and Answers

  • J
    johnathanhodgeJul 30, 2025
    Why won't my Yazoo/Kees ZKW42170 Lawn Mower engine start?
    • C
      Cory DavisJul 30, 2025
      If your Yazoo/Kees Lawn Mower engine won’t start, there are several things to check: * Ensure the blade switch is on. * Make sure the drive levers are in the neutral slots. * Confirm the operator is in the seat. * Verify the park brake isn't engaged. * Check the battery for a dead state or disconnected cables. * Ensure the ignition switch isn't left on. * Verify the fuel valve is open or in the correct position. * Make sure there is fuel in the tank. * Check if the spark plug wires are connected. * Inspect the spark plugs for damage.
  • M
    Martin RussoAug 3, 2025
    What to do if my Yazoo/Kees ZKW42170 Lawn Mower will not move or moves slowly?
    • J
      Jennifer MelendezAug 3, 2025
      If your Yazoo/Kees Lawn Mower isn't moving, is moving slowly, or is hard to move, check the following: ensure the park brake is off, verify that the pump bypass valves are closed, inspect the pump drive belt for looseness or disconnection, investigate for hydraulic system failure, and check for air in the hydraulic system.
  • J
    Jonathan SchroederAug 9, 2025
    What to do if the blades won’t engage on my Yazoo/Kees Lawn Mower?
    • M
      Mrs. Cheryl SanchezAug 9, 2025
      If the blades on your Yazoo/Kees Lawn Mower won’t engage, check if the blade belt is off the pulleys, ensure the clutch is hooked to the harness, test the blade switch for failure, and replace the burnt-out fuse.
  • B
    bclarkAug 14, 2025
    Why is my Yazoo/Kees ZKW42170 Lawn Mower cut uneven?
    • K
      kingzacharyAug 14, 2025
      An uneven cut from your Yazoo/Kees Lawn Mower can be caused by several factors. Make sure tire pressure is even at 15 psi on all tires. Also, check if the blades are bent, and inspect the air foil of the blade for wear or bending.
  • W
    wilsondarrylAug 19, 2025
    What to do if my Yazoo/Kees ZKW42170 Lawn Mower moves when in neutral position?
    • R
      Robin SerranoAug 19, 2025
      If your Yazoo/Kees Lawn Mower moves while in neutral, you should adjust the motion control linkage, check the pump arms for looseness or adjustment, and adjust the park brake.
  • D
    David ChapmanAug 25, 2025
    Why does my Yazoo/Kees ZKW42170 Lawn Mower pull to the left or right?
    • M
      Marilyn JonesAug 25, 2025
      If your Yazoo/Kees Lawn Mower pulls to the left or right, make sure the tire pressure is even. Also, adjust the motion control linkage, avoid operating on soft terrain, and do not operate on steep slopes.

Summary

Operators Manual Introduction

Model Information and Overview

Introduction to the operator's manual and models covered for the mower.

Safety Information

Warnings and Cautions

Critical safety alerts and precautions for safe mower operation.

Safety

Training and Preparation

Operator training, PPE, and pre-operation checks for safe use.

Operation

Safe operating practices, slope handling, and general precautions.

Transportation Safety

Guidelines for safely transporting the mower to and from locations.

Maintenance Safety

Safety measures to follow during routine maintenance procedures.

Setup and Adjustments

Equipment Setup

Steps for uncrating and setting up the mower before initial use.

Park Brake and Cutting Height

Procedures for adjusting the park brake and mower deck cutting height.

Belt Routing and Lever Adjustments

Adjustments for front deck belt routing, throttle, and reverse detent.

Motion Control Linkage

Detailed adjustment procedure for the motion control linkages.

Operating Instructions

Controls Identification

Identification and function of all mower controls for operation.

Starting and Operation

Step-by-step guide for starting the engine and operating the mower.

Maintenance

Blades Maintenance

Inspection, sharpening, and replacement of mower blades.

Routine Checks and Hardware

Daily checks for hardware, air cleaner, oil, tires, and battery.

Belts and Lubrication

Maintenance for drive belts and lubrication points on the mower.

Engine and Hydraulic Oil

Procedures for checking and changing engine and hydraulic oil.

Filters Maintenance

Procedures for fuel and hydraulic filter replacement.

Troubleshooting

Engine and Movement Issues

Solutions for common problems like engine not starting or mower not moving.

Blade and Cut Issues

Troubleshooting for blade engagement and cut quality problems.

Wiring Diagram

Electrical System Schematic

Detailed wiring diagram of the mower's electrical components.

Service Record

Maintenance Log Template

A log to record service dates and work performed on the mower.

Yazoo;Kees Limited Warranty

Warranty Coverage and Terms

Details of the two-year limited warranty coverage for mower products.

Obtaining Warranty Service

Procedure for locating dealers and getting warranty service.

Warranty Exclusions

Items and conditions not covered by the limited warranty.

Yazoo/Kees ZKW42170 Specifications

General IconGeneral
BrandYazoo/Kees
ModelZKW42170
CategoryLawn Mower
LanguageEnglish

Related product manuals