Z-Shade Lawn & Garden - User Manual

USER MANUAL
12_10 LG 12418
Z-Shade Co. Ltd.
(855) 4 Z-SHADE
(855) 497-4233
www.zshadeusa.com
Lawn & Garden
2 YEAR LIMITED WARRANTY
Z-Shade Co. Ltd., manufacturer of the product, warrants to the original purchaser who provides a dated sales receipt
from an Authorized Dealer, each part of the Z-Shade product to be free from defects in material or workmanship for a
period of two (2) years after the date of original purchase. The frame is covered under a limited two (2) year warranty
and guarantees the frame to be free from defects in material or workmanship. This warranty applies only for normal
and expected uses, as determined by the manufacturer.
Z-Shade Co. Ltd. obligation and liability under this warranty is limited to the replacement of the product or its parts, after
a review and examination of a submitted warranty claim.
Do not dispose of the shelter or any part of a shelter while claim is under review.
Warranty Claim Form can be downloaded from our website: www.zshadeusa.com
Please do not send any product to Z-Shade without prior written authorization.
REPLACEMENT PARTS: Parts can be ordered from our website: www.zshadeusa.com
If you need additional assistance regarding replacement parts, call us toll-free 855-497-4233
CONDITIONS: This warranty shall be void as to any product which has been altered or modified in any manner. This
warranty does not apply to damages caused by wind, rain, or other forces of nature, not to accidental or deliberate
damage of the product, nor to use of the product that does not conform with the product instructions.
This warranty is provided in lieu of all other warranties, expressed or implied.
©2018 Z-Shade Co. Ltd. All Rights Reserved.
PRODUCT INFORMATION:
Read this information before proceeding. It is the user’s responsibility to take the following precautions at all times.
• Do not use in any potentially windy or rainy weather. Wind and rain can damage your canopy and may also result in injury to you
or others. Therefore, do not rely on canopy for protection in heavy or prolonged rain storms.
• This product is designed as a temporary sun canopy. Do not leave up for extended periods.
• Always stake or weigh down your canopy.
• Use caution when handling the canopy’s frame. Avoid pinching hands or fingers as frame opens or closes.
• Do not use canopy in a lightning storm.
• Do not leave your canopy unattended.
• Do not build fires under canopy.
PRODUCT CARE & MAINTENANCE:
For long lasting durability and the best possible protection for your canopy, follow these care & maintenance instructions:
• Use a mild soap (not detergent) and plenty of water for top cleaning.
• Let the canopy top and frame dry completely before closing or storing to avoid mildew.
• The canopy frame will operate and look better if occasionally wiped with silicone spray, especially before and after use in damp
conditions. Remove excess silicone residue before attaching top.
• Slightly tighten bolts if frame becomes loose. Be careful not to over tighten bolts.
12
ft.
x 12
ft.
(3.7m x 3.7m)
10
ft.
x 10
ft.
(3.05m x 3.05m)

Summary

Product Information and Precautions

Safety Precautions for Canopy Use

User is responsible for taking precautions, including avoiding windy/rainy weather and lightning storms.

Product Care and Maintenance

Cleaning and Frame Maintenance

Clean with mild soap and water, dry thoroughly, and use silicone spray on frame for longevity.

2 Year Limited Warranty

Warranty Claims and Parts Information

Details warranty coverage, claim process, and how to order replacement parts via website or phone.

Package Contents

Initial Setup Procedure

Step-by-Step Assembly Guide

Instructions for unfolding the frame, attaching the top, and securing the canopy.

Canopy Take Down

Disassembly Instructions

Guide for safely lowering and closing the canopy, including frame and leg adjustments.

Canopy Setup Adjustments

Height Adjustment

Instructions on how to adjust the canopy legs to the desired height.

Skirt Attachment

Procedure for attaching the canopy skirts to the outer truss corners.

Overview

1. Function Description
2. Important Technical Specifications
3. Usage Features
4. Maintenance Features
5. Safety Precautions
6. Warranty Information

This document describes a Z-Shade canopy, a temporary sun shelter designed for lawn and garden use.

Function Description

The Z-Shade canopy serves as a temporary sun shelter, providing shade for outdoor activities. It is designed for quick setup and takedown, making it suitable for events or temporary outdoor use. The canopy is not intended for protection against heavy or prolonged rain storms, strong winds, or lightning.

Important Technical Specifications

The manual details two available sizes for the canopy:

• 12ft. x 12ft. (3.7m x 3.7m)
• 10ft. x 10ft. (3.05m x 3.05m)

The package includes:

• Z-Shade Frame
• Polyester Top
• Roll Away Bag
• 4-Piece Leg Skirts
• 4-Piece Stake Kit

The product features flame-resistant fabric that meets CPAI-84 specifications, though it is explicitly stated that the fabric is not fireproof and will burn if left in continuous contact with any flame source.

Usage Features

The canopy is designed for ease of use with features like push-button mechanisms for setup, takedown, and height adjustment.

Initial Setup:

1. Unfolding the Frame: Two partners grasp two outer legs, lift slightly, and step backward to full arms' length.
2. Attaching the Top: The polyester top is unfolded and placed over the open frame, aligning its corners with the frame's corners. The canopy locking strips are then attached to the frame's locking strips, and the corners are pulled down fully.
3. Opening the Canopy: With partners on opposite sides, the frame is placed in the center of the shaded area. Two partners grasp the top and bottom of the truss on opposite sides, lift the canopy slightly, and push hands together while stepping backward until the canopy is fully opened. Caution is advised to avoid pinching fingers or pushing too hard.
4. Lowered Canopy (Raising): With the canopy in a lowered position, partners walk underneath. One hand pushes hub (A) up the runner while the other hand holds the upper frame until snap button (B) locks.
5. Securing the Top: The polyester top is secured to the frame by locking the strips around the trusses. This is repeated for all strips.
6. Top Vent: The vents are opened by propping up the supporting strips.
7. Extending Legs: Partners lift outer legs, slide out the inner legs until the push button locks into the outer legs. This is repeated for remaining legs.

Skirts Setup:

1. Attaching Skirts: Skirt clips are locked onto the bottom of the outer truss at adjacent corners. This is repeated for the remaining corners.
2. Unfolding Fabric: The top canopy fabric is unfolded back down to cover each corner skirt, repeated for the remaining corners.

Height Adjustment:

• A push button allows adjustment of the legs to the desired height. This is repeated for all remaining legs.

Maintenance Features

The manual provides specific instructions for care and maintenance to ensure long-lasting durability and protection:

• Cleaning: Use a mild soap (not detergent) and plenty of water for cleaning the top.
• Drying: The canopy top and frame must be dried completely before closing or storing to prevent mildew.
• Frame Lubrication: The canopy frame's operation and appearance can be improved by occasionally wiping it with silicone spray, especially before and after use in damp conditions. Excess silicone residue should be removed before attaching the top.
• Tightening Bolts: If the frame becomes loose, bolts should be slightly tightened, taking care not to overtighten them.

Safety Precautions

The manual emphasizes several safety precautions:

• Weather Conditions: Do not use in windy or rainy weather, as wind and rain can damage the canopy and cause injury. It is not designed for protection in heavy or prolonged rain storms.
• Temporary Use: The product is a temporary sun canopy and should not be left up for extended periods.
• Securing: Always stake or weigh down the canopy.
• Frame Handling: Use caution when handling the frame to avoid pinching hands or fingers.
• Lightning: Do not use the canopy in a lightning storm.
• Supervision: Do not leave the canopy unattended.
• Fire Hazards: Do not build fires under the canopy. Keep all flame and heat sources away from product fabrics, as the flame-resistant fabric is not fireproof and will burn if in continuous contact with a flame source.

Warranty Information

The product comes with a 2-year limited warranty from Z-Shade Co. Ltd. This warranty covers defects in material or workmanship for both the product and its frame, starting from the original purchase date with a dated sales receipt from an Authorized Dealer. The warranty applies only to normal and expected uses as determined by the manufacturer.

Warranty Claim Process:

• Z-Shade Co. Ltd.'s liability is limited to the replacement of the product or its parts after a review and examination of a submitted warranty claim.
• Customers should not dispose of the shelter or any part while a claim is under review.
• A Warranty Claim Form can be downloaded from www.zshadeusa.com.
• Products should not be sent to Z-Shade without prior written authorization.

Replacement Parts:

• Parts can be ordered from www.zshadeusa.com.
• For additional assistance, customers can call toll-free: 855-497-4233.

Warranty Conditions (Void if):

• The product has been altered or modified.
• Damage is caused by wind, rain, or other forces of nature.
• Damage is accidental or deliberate.
• The product is used in a manner that does not conform with the product instructions.

This warranty is provided in lieu of all other expressed or implied warranties.

Z-Shade Lawn & Garden Specifications