1
1.INTRODUCTION
ZEKS’ Non-Cycling refrigerated air dryer removes moisture, oil vapor, and other contami-
nants from compressed air. These contaminants are detrimental to pneumatically
operated equipment, controls, instruments, machinery and tools. This removal is
accomplished by cooling the air with a refrigeration unit to a temperature at which
moisture in the air is condensed and separated from the air stream. The temperature the
air is cooled to, normally between 36° and 40°F (2° and 4°C), is known as dew point.
This dryer can be easily installed into various pneumatic systems in which dry air is
required or desired. Please refer to Principles of Operation for complete operating details.
• For warning label information with French translations, refer to pages 5 and 6.
• Pur obtenir l’informatione des etiquettes dangereuses avec la traductione en francais, s’il vous plait
consul ter les pages 5 and 6.
2.ABBREVIATED WARRANTY
ZEKS refrigerated dryers are warranted to be free from defects in material and workman-
ship for a period of 12 months from the original date of shipment from the factory. To
allow the warranty to be in effect for 12 months from the date of equipment start-up, the
Warranty Registration Card must be completed and returned to ZEKS. Alternately, the
Warranty Registration Card may be completed online at www.zeks.com. The total
warranty period cannot exceed 18 months from the original date of shipment from the
factory.
Equipment must be installed and operated in accordance with ZEKS’ recommendations.
ZEKSliability is limited to repair of, refund of purchase price paid for, or replacement in
kind at ZEKS’ sole option, during the warranty time period stated above. IN NO EVENT
SHALL ZEKS BE LIABLE OR RESPONSIBLE FOR INCIDENTAL OR CONSEQUENTIAL
DAMAGES, even if the possibility of such incidental or consequential damages has been
made known to ZEKS Compressed AirSolutions. In addition, the usual maintenance and
replacement type products are not covered by this warranty.
HEAT EXCHANGERS
Dryers that utilize CFX heat exchanger technology (HSF, HSG, NCE, NCF & NCG) are
covered for a total of 10 years from the original date of shipment from the factory.
Following the standard warranty terms the available warranty is as stated below. The
exchanger warranty applies to the replacement exchanger only and does not cover any
labor expenses.
Prorated coverage of prices from date of shipment from the factory:
18 to 48 months 100%
49 to 60 months 70%
61 to 72 months 50%
73 to 84 months 30%
85 to 96 months 20%
97 to 120 months 10%
REFRIGERANT COMPRESSORS
A prorated warranty for the replacement of the refrigerant compressor will be extended to
a maximum of 60 months (5 years) from the original date of shipment from the factory.
To Next Page
Loading...
