A.O. Smith Gphe 50 - Troubleshooting Guidelines (Continued); Common Problems, Causes, and Solutions

A.O. Smith Gphe 50

40 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

37

Theseguidelinesshouldbeutilizedbyaqualiedserviceagent.

TROUBLESHOOTING GUIDELINES

TROUBLESHOOTING GUIDELINES

Table of Contents

For Your Safety1
Safe Installation, Use and Service2
Approvals2
General Safety Information3
Table of Contents5
Introduction5
- Qualified Installer Or Service Agency5
- Preparing for the Installation5
Installation Requirements for the Commonwealth of Massachusetts6
Typical Installation7
- Mixing Valves9
Locating the New Water Heater10
- Facts to Consider about Location10
- Insulation Blankets11
- Air Requirements11
- Unconfined Space12
- Confined Space12
- Fresh Air Openings For Confined Spaces12
- Outdoor Air through Two Openings12
- Outdoor Air through One Opening12
- Outdoor Air through Two Horizontal Ducts13
- Outdoor Air through Two Vertical Ducts13
- Air from Other Indoor Spaces13
Installing the New Water Heater14
- Chemical Vapor Corrosion14
- Water Piping14
- Space Heating & Potable Water System14
- Closed Water Systems14
- Thermal Expansion15
- Temperature-Pressure Relief Valve15
- Temperature-Pressure Relief Valve16
- High Altitude Installation16
- Gas Piping16
- Sediment Traps17
- Filling the Water Heater17
- Vent Pipe Assembly18
- Venting18
- Vent Pipe Termination19
- Planning the Vent System20
- Condensate20
- Condensate21
- Blower Assembly Installation21
- Installation of Vent System21
- Vent Terminal Installation, Sidewall21
- Installation of Vent System, Sidewall23
- Installation of Vertical Vent System23
- Vent Attenuation Assembly Installation Instructions24
- Vent Pipe Preparation26
Lighting & Operating Label28
Temperature Regulation29
For Your Information30
- Start up Conditions30
- Operational Conditions30
Periodic Maintenance30
- Venting System Inspection30
- Burner Operation and Inspection31
- Burner Cleaning31
- Housekeeping31
- Anode Rod Inspection31
- Temperature-Pressure Relief Valve Test32
- Draining and Flushing32
- Service33
Leakage Checkpoints33
Repair Parts List34
Troubleshooting Guidelines35
Troubleshooting Guidelines37
Notes38
Limited Warranty39

Related product manuals

A.O. Smith AOS GPHE-50

Preview: A.O. Smith GPVL-50

A.O. Smith GPVL-50

Preview: A.O. Smith GDHE-50

A.O. Smith GDHE-50

A.O. Smith GCVX-50

A.O. Smith GCVT-50

A.O. Smith ProMax GVC-50

Preview: A.O. Smith GDHE-50 SERIES

A.O. Smith GDHE-50 SERIES

A.O. Smith ProMax GCVL-50

A.O. Smith FPSH 50

Preview: A.O. Smith XCRX-50-LP

A.O. Smith XCRX-50-LP

Preview: A.O. Smith Vortex HPTU-50

A.O. Smith Vortex HPTU-50

Preview: PGX 30, PGX 40, PGX 50, PGXH 30, PGXH 40, PGXH 50, PGR 30, PGR 40, PGR 50, PGXL 30, PGXL 40

PGX 30, PGX 40, PGX 50, PGXH 30, PGXH 40, PGXH 50, PGR 30, PGR 40, PGR 50, PGXL 30, PGXL 40