27
26
C=Check CA= Check Adjust R=Replace S=Service
CL= Clean and Lubricate
L=Lubricate
MAINTENANCE
Remarks
Pre-
Operation
20 rounds
20 hours
20 hours
160kms(
Every
Month)
125
rounds
125 hours
600 miles
1000kms (
Every 6
250 rounds
250 hours
1200 miles
1000kms(
Every
Years)
500 rounds
500 hours
2500 miles
4000kms(
Every 2
Years)
1000
rounds
1000 hours
5000 miles
8000kms
(Every 4
Page
Charge
Clean Batt e r y t o ps,for
tightness of hold-down screws
and terminals
Check brake pedal freeplay and
adjust if necessary
Check steering operation
Check tire pressure tread
depth tire surface for damage
Check bod e and chassis ,f or damage
Check tight ne ss of all bo lts,nuts and
screw
Check reverse buzzer
Pre-Operation
Every month
Check electrolyte level
C h e c k f o r l o o s e o r b r o k e n
connect ionsw
C l e a n L u b e P e d a l
control area
Check all wire insulation for crack
and/or worn spots
Check shock absorbers for oil
leaks and damaged springs
Perform a discharge test
protectant
Check shoe lining thickness
and rear axle beating play
C h e c k s t e er i n g k n uc k l e
bushing freeplay/Adjust wheel
alighment
Ch eck wh eel no t t igh tness
front wheel bearing play
Check gear box oil level and
leakage
C h e c k f o r g r e a s e
lea kage ;adj ust gear box if
Replace gear box oil
Check operati on and a dj ust pe dal
stop if nec essary
Every 6 month
Every year
Every 4 month
Items without a page number referene should be serviced by approved
agent or qualified technician.
This manual doesn't contain these procedures.They are containerd in the
Service Manual
STORAGE
BATTERY PREPARATION
N O T E :
CHASSIS PREPARATION
C A U T I O N
Perform the following prepararions when
leaving your golf car unused for a long
time:
Turn the main switch key to the “OFF”
position , remove the key , and put it in a
safe place .
1. Verify the air pressure of the tire is
25psi ( 3 kgf/cm3);
2. Clean the outside of the car with anti-
rust oil;
3. Cover the car and store it in a dry and
well-ventilated place.
1.R e charge the batt e ries and
check the fluid levels at least once
a month .
2.Disconnecting cables in case of
long storage
Cleaning products are forbidden to
put into battery cells
3. Clean the top of the batteries with
baking soda and water so as to avoid
errosion.
To Next Page
Loading...
