Air-Flo Quick-Silver - Page 43




CONDITION
CONDITIONCONDITION
CONDITION POSSIBLE CAUSE
POSSIBLE CAUSEPOSSIBLE CAUSE
POSSIBLE CAUSE CORRECTION
CORRECTIONCORRECTION
CORRECTION
Excessive load on vehicle electrical system
while using snow plow.
1) Too many accessories on.
2) Hydraulic fluid not correct for outside tem-
perature.
3) Quill adjusted in too far.
4) Vehicle battery weak or charging system
Malfunction.
5) Worn or damaged motor or pump, or fault in
wiring.
1) Turn off unnecessary accessories.
2) Use recommended fluid.
3) Adjust Quill out.
4) Replace battery and/or check charging sys-
tem.
5) See an Air-Flo dealer for repair information.
Vehicle battery loses charge when snow plow
is not being used.
1) Vehicle battery weak.
2) Fault in wiring.
1) Replace battery.
2) See an Air-Flo dealer for repair information.
Snow plow headlamps operate irregularly or
not at all (snow plow attached).
1) Snow plow wire harness not connected.
2) Burned out bulbs or vehicle fuse.
3) Fault in wiring.
1) Properly connect wire harness.
2) Replace bulbs, clean contacts.
3) See an Air-Flo dealer for repair information.
manual-final.qxd 11/17/2006 12:45 PM Page 43