CONDENSED SERVICE DATA
(WD 45 Diesel)
WD 45
GENERAL
Tractor
Model
Engine Make
Engine Model 45D
Cylinders 6
Bore.
Inches 3 7/16
Stroke, Inches 4 1/8
Displacement. Cubic Inches 230
Compression Ratio 15.5:1
Pistons Removed From? Above
Main Bearings, Number of 7
Main Bearings, Adjustable? No
Rod Bearings. Adjustable? No
Cylinder Sleeves Wet
Generator. Make D-R
Starter, Make D-R
Injection Nozzle. Make Bosch
Injection Pump, Make Bosch
Injection Pump. Model PSB
TUNE-UP
Firing Order
1-5-3-6-2-4
Valve Tappet Gap. Inlet 0.010 H
Valve Tappet Gap, Exhaust 0.019 H
Inlet Valve Face Angle 45"
Exhaust Valve Face Angle 45°
Inlet Seat Angle
45**
Exhaust Seat Angle 45"
Injection Timing. Degrees BTC ' 21
Timing Mark Location Flywheel
TUNE<UP (Conf.)
Tractor WD 45
Model Diesel
Engine Low Idle RPM 600
Engine High Idle RPM 1975
Engine Loaded RPM 1625
Belt Pulley Loaded RPM 1460
PTO Loaded RPM 548
SIZES-CAPACITIES-CLEARANCES
(Clearances in Thousandths)
Crankshaft Journal Diameter
2.4975
Crankpin Diameter
1.998
Camshaft Journal
Diameter,
Numbers
1. 2 and 3
1.9985
Camshaft Journal
Diameter,
Number
4
1.2485
Piston
Pin
Diameter
0.9996
Valve Stem Diameter
0.3095
Compression
Ring.
Width
1/8
OU
Ring.
Width
3/16
Main
Bearings,
Diameter Clearance
2.3-4.5
Rod
Bearings,
Diameter Clearance
1.5-3.5
Piston Skirt Clearance
4-5
Crankshaft
End
Play
2-7
Camshaft Bearing Clearance
: 2-4.6
Cooling System. Gallons
4 V4
Crankcase Oil. Quarts (With FUter) 7
TIGHTENING TORQUE-Ft.-Lbs.
Connecting Rod Nuts 30-40
Cylinder Head Nuts 95-100
Flywheel Screws ,... 95-105
Main Bearing Screws 125-135
MODEL WD45 DIESEL
To Next Page
Loading...
