Amsco 3085 SP - Page 40

6-2
150830-026 Operator Manual Routine Maintenance
4.0 CONTROLS
4.1 Verify proper operation of all articulations for full motion.
• Using hand control. 6x per year
• Using override function. 6x per year
• Using manual control (foot pump). 6x per year
• Using foot control, if equipped. 6x per year
• Using battery power, if equipped. 6x per year
4.2 Check integrity of hand control and cord. 6x per year
5.0 ELECTRICAL CHECKS
5.1 Ensure all circuit board connectors and cable plugs are tight. 6x per year
5.2 Check all cables for damage or fraying. 6x per year
5.3 Verify battery charger voltage (28.5 Volts ± 1 percent, motor battery charger at
P20; 28.3 Volts ± 1 percent, control battery charger at S1/S5 terminals). 2x per year
5.4 Verify battery voltage (13.6-13.8 Volts per battery fully charged at 77°F [25°C]). 2x per year
6.0 TABLE RIGIDITY
6.1 Check tabletop for any horizontal or vertical play. 2x per year
6.2 Check side tilt mechanism for any play and ensure screws on the top clevis and 2x per year
bottom support bracket are secure.
6.3 Lubricate column guide rails. 1x per year
7.0 FINAL TEST
7.1 Secure all covers and shrouds. 6x per year
7.2 Reinstall any pads that were removed. Check for rips, tears, etc. 6x per year
7.3 Check area to ensure removal of all materials used during inspection. 6x per year
Table 6-1. Preventive Maintenance Schedule for Amsco 3085 SP Surgical Table (Cont'd)
SERVICE REQUIRED MINIMUM FREQUENCY
Table 6-2. Recommended Cleaning Products*
Product Name Product Use
Coverage
®
Spray HB Ready-to- Hospital-grade quaternary-based
Use Disinfectant Cleaner disinfectant spray
Coverage
®
HB Concentrate EPA-registered Hepatitis-B-effective quat
T.B.Q.
®
Hard Surface Detergent-based germicide
Disinfectant Cleaner
Coverage Plus
®
Concentrated One-step germicide disinfectant cleaner
Disinfectant Cleaner
Coverage
®
Spray Ready-to- General cleaner/disinfectant formulated
Use Disinfectant Cleaner with quarternary ammonium compounds
and nonionic detergents
Germicidal Cloth Impregnated Surface disinfectant
Non-Woven Disposable Cloth
* Contact STERIS for ordering information.