53
General Maintenance
NOTE: Proper maintenance of the ATV is important for optimum per-
formance. Follow the Maintenance Schedule and all ensuing mainte-
nance and care instructions/information.
NOTE: Proper maintenance procedures for each item can be found on
the corresponding page indicated.
If, at any time, abnormal noises, vibrations, or improper functioning of any compo-
nent of this ATV is detected, DO NOT OPERATE THE ATV. Take the ATV to an
authorized Arctic Cat ATV dealer for inspection and adjustment or repair.
If the owner/operator does not feel qualified to perform any of these maintenance
procedures or checks, take the ATV to an authorized Arctic Cat ATV dealer for pro-
fessional service.
I = Inspect and clean, adjust, lubricate, replace as necessary T = Tighten C = Clean
* = Dealer maintenance
Maintenance Schedule
Item Page
After
break-in
(100 miles)
1 month 3 months 6 months
Air filter (Engine) 63 I I
Air filter (V-belt housing) 62 I I
Battery 58 I I
* Brake components 57 I Inspect every time before riding
Brake fluid 57 I *Replace every 2 years
Brake hoses 57 I *Replace every 4 years
* Chassis nuts and bolts — I T
Cooling system 54 I Inspect every time before riding
Electrical connections — I I
* Engine nuts and bolts — I I
Engine oil 55 C C
Frame/welds/racks — I I
Gas/vent hoses 49 I Inspect every time before riding
49 Replace every 2 years
Headlight/taillight-brakelight 66 I Inspect every time before riding
Idle RPM 61 I I
Rear drive lubricant (Utility) 56 Replace every 12 months
Drive Chain (DVX) 64 I Inspect every time before riding
Spark arrester/muffler 66 C
Spark plug 61 I I I
61 Replace every 18 months
* Steering — I Inspect every time before riding
* Suspension
(Ball joint boots and tie rod boots)
— I Inspect every time before riding
Throttle cable 62 I Inspect every time before riding
Tires/air pressure 65/29 I Inspect every time before riding
Transmission lubricant 56 Replace every 12 months
* Valve clearance — I I
To Next Page
Loading...
