INST 318 HINRG HEATER ā V01-18
MAINTENANCE OF YOUR POOL HEATER
Maintenance Schedule: You new product incorporates moving parts and withstands high velocity water with chemicals in it.
Some of these parts will wear in the normal course of use and require regular checks and maintenance. Performing these checks
and maintenance will identify parts that have worn and require repair/replacement before further serious damage is sustained.
A small amount of regular care and attention to your pool equipment will help ensure long life and trouble free performance.
To protect against extremes of temperature, your unit is vented to allow expensive electronics to cool. Ants and
some insects are often attracted to the warmer, dry environment inside the enclosure. We recommend that, with
power turned off, you spray a surface insecticide on the surfaces surrounding the control to prevent ant and
insect ingress. Repeat every three months or as necessary
Service action (if required)
Operate heater for 15 min to clear residues and
ensure correct operation
Start circulation pump and turn heater on,
leaving to run for a few minutes. This will
clear flue passages and keep components
working properly
Check inlet/outlet O-rings for leaks
Check for insert/ants
Isolate Pump, turn power off, clean and
grease O rings or replace if necessary
Turn Power off to Heater, Spray a surface
insecticide on the surfaces around the unit
to prevent ant and insect ingress.
Check surroundings for leaves, debris and
flooding
Remove debris from around the base of the
hearer and rectify if any flooding. Clear
vegetation from around the flue
Check gas pressures
Check Burner, pilots and ignition systems
Call Service technician to perform annual gas
checks and routine maintenance
Must be completed by an authorised person
Important note: Regular maintenance is important to ensure long life and trouble free performance of your pool equipment. If
unable to perform the maintenance yourself, contact your local AstralPool office who will arrange a trained service technician to
perform the maintenance for you.
WARRANTY TERMS AND CONDITIONS
Astral Pool Australia Pty Ltd (ABN 97 007 284 504) ("Astral Pool") provides the following warranty in relation to its HiNRG series gas
pool & spa heaters.
The benefits of this warranty are in addition to any rights and remedies imposed by Australian state and federal legislation that
cannot be excluded. Nothing in this warranty is to be interpreted as excluding, restricting or modifying any state or federal
legislation applicable to the supply of goods and services which cannot be excluded, restricted or modified.
WARRANTY
Astral Pool warrants that, subject to the exclusions and limitations below, the product will be free from defects in materials and
workmanship during the warranty period. The warranty periods are set out below and commence 30 days after the date of
purchase (to allow for installation) subject to the exclusions listed below. The warranty period may vary for different parts of the
Product.
Cabinet, refractory insulation and combustion
chamber
Components such as gas valve, thermostat, pilot,
wiring, burner, gaskets
Heat exchanger, inlet and return water headers
10,000 hours or 7,000 ignition attempts as
counted on the HiNRG control module
To Next Page
Loading...
