Audi A6 Avant 2011 - Power and Control Electronics for Electric Drive JX1

Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
6.3 Power and control electronics for elec‐
tric drive - JX1-
6.3.1 General description
The power and control electronics for electric drive - JX1- -1- act
as the link between the electric drive motor - V141- and the hybrid
battery unit - AX1- . It contains the electric drive control unit -
J841- , the voltage converter - A19- , the intermediate circuit
capacitor 1 - C25- and the DC/AC converter for drive motor -
A37- .
For driving with the electric drive motor - V141- , the DC/AC con‐
verter for drive motor - A37- converts the 266 V direct current of
the hybrid battery unit - AX1- into 360 V alternating current. The
voltage converter - A19- converts high voltage into low voltage to
supply the 12 V electrical system. Power and control electronics
for electric drive - JX1- are water-cooled and are installed in en‐
gine compartment (front left).
The following high-voltage wires are connected to the power and
control electronics for electric drive - JX1- :
♦ High-voltage wire for hybrid battery, positive terminal - P1- to
hybrid battery unit - AX1- ⇒ page 38
♦ High-voltage wire for hybrid battery, negative terminal - P2- to
hybrid battery unit - AX1- ⇒ page 38
♦ High-voltage wire 1 for drive motor - P4- to electric drive motor
- V141- ⇒ page 43 .
♦ High-voltage wire 2 for drive motor - P5- to electric drive motor
- V141- ⇒ page 43 .
♦ High-voltage wire 3 for drive motor - P6- to electric drive motor
- V141- ⇒ page 43 .
♦ High-voltage wire for electrical air conditioner compressor -
P3- to electrical air conditioner compressor - V470-
⇒ page 49 .
Note
♦ Fuse for electrical air conditioner compressor - JX1- is inte‐
grated into power and control electronics for electric drive -
V470- .
♦ Fuse cannot be renewed. Power and control electronics for
electric drive - JX1- cannot be dismantled any further. If dam‐
aged, renew power and control electronics for electric drive -
JX1- .
Potential equalisation line on power and control electronics for
electric drive - JX1- ⇒ page 11 .
6.3.2 Overview
Audi A6 2011 ➤ , Audi A6 Avant 2011 ➤
Electrical system, hybrid - Edition 03.2014
26 Rep. gr.93 - Electric drive systems