Audi Q5 2008 - Page 71

Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
10 - Condenser
❑ If a fluid reservoir with dryer cartridge is installed at the condenser, the dryer cartridge must be removed
(reseal fluid reservoir at or in condenser). Refer to ⇒ Heating, Ventilation and Air Conditioning; Rep. Gr.
87 ; Removal and Installation (vehicle-specific repair manual).
❑ If the fluid reservoir is directly installed at the condenser, the fluid reservoir must be removed and replaced
only after flushing. Refer to ⇒ Heating, Ventilation and Air Conditioning; Rep. Gr. 87 ; Removal and
Installation (vehicle-specific repair manual).
Note
11 - High Pressure Side Connection On Refrigerant Circuit
❑ Different versions depending on vehicle. Refer to
⇒ “2.1.2 Adapter for Assembling Flushing Circuit“, page 42 .
12 - Adapter To Connection For High Pressure Side On Refrigerant Circuit
❑ Different versions depending on vehicle. Refer to
⇒ “2.1.2 Adapter for Assembling Flushing Circuit“, page 42 .
❑ From VW/Audi passenger vehicle set adapter chest -VAS 6338/1- .
13 - Charge Hose For Refrigerant Circuit Flushing Device
❑ From connection to the high pressure side of the A/C compressor on the refrigerant circuit (smaller
diameter) to input of refrigerant circuit flushing device.
14 - Refrigerant Circuit Flushing Device
❑ There are different versions of the Refrigerant circuit flushing device . Refer to the Special Tools and
Equipment Catalog.
❑ With filter, viewing glass, security valve, heater, refrigerant container, etc. (depending on version).
❑ Depending on the construction of the A/C service station and of refrigerant circuit flushing device, a
check-valve may be installed at output of refrigerant circuit flushing device (to guarantee correct direction
of refrigerant flow during flushing).
15 - Refrigerant Hose Of A/C Service Station
❑ From low pressure side of A/C service station (mostly colored blue) to output of refrigerant circuit flushing
device.
16 - Adapter For Sealing Outlet To The Second Evaporator
❑ Only necessary on certain vehicles with optional equipment of second evaporator.
❑ From VW/Audi passenger vehicle set adapter chest -VAS 6338/1- .
17 - Adapter For Sealing Outlet To The Second Evaporator
❑ Only necessary on certain vehicles with optional equipment of second evaporator.
❑ From VW/Audi passenger vehicle set adapter chest -VAS 6338/1- .
18 - Low Pressure Side Connection On Refrigerant Circuit To Second Evaporator
❑ Different versions depending on vehicle. Refer to
⇒ “2.1.2 Adapter for Assembling Flushing Circuit“, page 42 .
❑ Only present on certain vehicles with optional equipment of second evaporator.
19 - High Pressure Side Connection On Refrigerant Circuit To Second Evaporator
❑ Different versions depending on vehicle. Refer to
⇒ “2.1.2 Adapter for Assembling Flushing Circuit“, page 42 .
❑ Only present on certain vehicles with optional equipment of second evaporator.
20 - Adapter For The Removed Expansion Valve On Second Evaporator
❑ Different versions depending on vehicle. Refer to
⇒ “2.1.2 Adapter for Assembling Flushing Circuit“, page 42 .
❑ Only necessary on certain vehicles with optional equipment of second evaporator.
❑ From VW/Audi passenger vehicle set adapter chest -VAS 6338/1- .
21 - Second Evaporator
❑ Only present on certain vehicles with optional equipment of second evaporator.
Audi 100 1991 ➤ , Audi 80 1992 ➤ , Audi A1 2011 ➤ , Audi A2 2001 ➤ , A ...
Refrigerant R134a Servicing - Edition 01.2011
2. Description and Operation 67