Backyard GBC1305W - Page 11

Need help? 1.800.762.1142
Do not return to place of purchase.
Recipes
BlueRhino.com/recipes
Replacement Parts
parts.BlueRhino.com /
1.800.762.1142
PAGENO

Troubleshooting
Problem Possible Cause Prevention/Cure
Burner will not light using ignitor
LP gas tank valve is closed
Make sure regulator is securely attached to the LP gas tank, turn LP gas tank
VALVETOh/0%.v
,0GASTANKISLOWOREMPTY 2EPLACEORREFILL,0GASTANK
LP gas leak
4URN,0GASTANKVALVETOh#,/3%$v
7AITMINUTESFORGASTOCLEAR
&OLLOWh#HECKINGFOR,EAKSvINTHEOWNERSMANUAL
Battery needs to be changed 2EPLACETHEh!!vBATTERYFOLLOWASSEMBLYSTEPFORINSERTINGBATTERY
7IRESORELECTRODECOVEREDWITHCOOKINGRESIDUE #LEANWIREANDORELECTRODEWITHRUBBINGALCOHOL
%LECTRODEANDBURNERSAREWET 7IPEDRYWITHCLOTH
%LECTRODECRACKEDORBROKENSPARKSATCRACK 2EPLACEELECTRODE
Wire loose or disconnected 2ECONNECTWIREORREPLACEELECTRODEWIREASSEMBLY
7IREISSHORTINGSPARKINGBETWEENIGNITORANDELECTRODE 2EPLACEIGNITORWIREELECTRODEASSEMBLY
Bad ignitor 2EPLACEIGNITOR
Burner will not light with match
.OGASFLOW
#HECKIF,0GASTANKISEMPTY
!)FEMPTYREPLACEORRElLL
")F,0GASTANKISNOTEMPTYREFERTOh3UDDENDROPINGASmOWORREDUCED
mAMEHEIGHTv
,0GASTANKISLOWOREMPTY 2EPLACEORREFILL,0GASTANK
LP gas leak
4URN,0GASTANKVALVETOh#,/3%$v
7AITMINUTESFORGASTOCLEAR
&OLLOWh#HECKINGFOR,EAKSvINTHEOWNERSMANUAL
#OUPLINGNUTANDREGULATORNOTFULLYCONNECTED
4URNINGTHECOUPLINGNUTABOUTONEHALFTOTHREEQUARTERSADDITIONALTURNUNTIL
SOLIDSTOPTighten by hand only-do not use tools.
/BSTRUCTIONOFGASFLOW
#LEARBURNERTUBES
#HECKFORBENTORKINKEDHOSE
Disengagement of burner to valve Reengage burner and valve
3PIDERWEBSORINSECTNESTINVENTURI Clean venturi and burner tube
"URNERPORTSCLOGGEDORBLOCKED #LEANBURNERPORTS
Sudden drop in gas flow or reduced flame height
/UTOFGAS 2EPLACEORREFILL,0GASTANK
%XCESSFLOWSAFETYDEVICEMAYHAVEBEENACTIVATED
4URNCONTROLKNOBSTO“
/&&v
7AITSECONDSANDLIGHTGRILL
)FmAMESARESTILLTOOLOWRESETTHEEXCESSIVEmOWSAFETYDEVICE
a. Turn control knob(s) “
/&&v
B4URN,0GASTANKVALVETOh#,/3%$v
c. Disconnect regulator
d. Turn control knobs to
()'(
E7AITMINUTE
f. Turn control knobs to “
/&&v
g. Reconnect regulator and leak check connections
H,IGHTGRILLPERh,IGHTING)NSTRUCTIONSv
Irregular flame pattern, flame does not run the
full length of burner
"URNERPORTSARECLOGGEDORBLOCKED #LEANBURNERPORTS
Flame is yellow or orange
.EWBURNERMAYHAVERESIDUALMANUFACTURINGOILS
"URNGRILLFORMINUTESON
()'(WITHTHELIDCLOSED
3PIDERWEBSORINSECTNESTINVENTURI Clean venturi
&OODRESIDUEGREASEETC Clean burner
Poor alignment of valve to burner venturi !SSUREBURNERVENTURIISPROPERLYENGAGEDWITHVALVE
Flame blow out
(IGHORGUSTINGWINDS $ONOTUSEGRILLINHIGHWINDS
,OWON,0GAS 2EPLACEORREFILL,0GASTANK
%XCESSFLOWVALVETRIPPED 2EFERTOh3UDDENDROPINGASFLOWORREDUCEDFLAMEHEIGHTv
Flare-up
'REASEBUILDUP
2EMOVEANDCLEANALLGRILLPARTSPERh#LEANINGAND#AREvINSTRUCTIONSINTHE
OWNERSMANUAL
%XCESSFATINMEAT Trim fat from meat before grilling
%XCESSIVECOOKINGTEMPERATURE !DJUSTLOWERCOOKINGTEMPERATURE
Persistent grease fire
'REASETRAPPEDBYFOODBUILDUPAROUNDBURNERSYSTEM
4URNCONTROLKNOBSTO“
/&&v
4URN,0GASTANKVALVETOh#,/3%$v
,EAVELIDINCLOSEDPOSITIONANDLETlREBURNOUT
!FTERGRILLCOOLSREMOVEANDCLEANALLPARTSPERh#LEANINGAND#AREv
INSTRUCTIONSINTHEOWNERSMANUAL
Flashback (fire in burner tube(s))
Burner and/or burner tubes are blocked Clean burners and/or burner tubes
Inside of lid is peeling (like paint peeling)
4HELIDISSTAINLESSSTEELNOTPAINTED
"AKEDONGREASEBUILDUPHASTURNEDTOCARBONANDISFLAKINGOFFCLEAN
THOROUGHLYPERh#LEANINGAND#AREvINSTRUCTIONSINTHEOWNERSMANUAL
4HELIDISCOATEDPAINTED
s4HISCANBEFROMBAKEDONGREASEBUILDUPTHATHASTURNEDINTOCARBONANDIS
flaking off
s#LEANTHOROUGHLYPERh#LEANINGAND#AREvINSTRUCTIONSINTHEOWNERSMANUAL
s!FTERCLEANINGIFYOUCANSEESTEELPLEASECALL#USTOMER#AREAT

For more assistance please visit us online at www.BlueRhino.com or call 1.800.762.1142.