EasyManua.ls Logo

Backyard GBC1707WT-C - User Manual

Backyard GBC1707WT-C
37 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
.
Natural gas conversion kit (model no.
VFK1702W-C) available at Walmart or
www.Walmart.ca
OWNER’S MANUAL
Table of Contents
Important Safeguard
s ....................
Page 2
Expanded View & Hardware ................. 6 &7
Assembly Instructions........................ 8
Installing LP Gas Tank....................... 13
Operating Instructions....................... 13
Cleaning and Care ......................... 15
Limited Warranty .......................... 16
Troubleshooting ........................... 17
The use and installation must conform with local
codes or, in the absence of local codes, with either the
National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural
Gas and Propane Installation Code, CSA B149.1, or
Propane Storage and Handling Code, B149.2, or the
Standard for Recreational Vehicles, ANSI A 119.2/NFPA
1192, and CSA Z240 RV Series, Recreational Vehicle
Code, as applicable.
THIS INSTRUCTION BOOKLET CONTAINS IMPORTANT
SAFETY INFORMATION. PLEASE READ AND KEEP FOR
FUTURE REFERENCE.
If you are assembling this unit for someone else, give
this manual to him or her to read and save for future
reference.
Outdoor LP Gas Barbecue Grill
Model No. GBC1707WT-C
.
Manufactured in China for: RevoAce Inc. Limited
Hong Kong, China
1.800.694.0013 • service@revoace.com
8:00 am to 4:00 pm central time, Monday to Friday.
.
WARNING
FOR YOUR SAFETY:
1. Do NOT store or use gasoline or
other flammable liquids or vapors in
the vicinity of this or any other
appliance.
2. An LP cylinder not connected for
use shall not be stored in the vicinity
of this or any other appliance.
DANGER
Never operate this appliance
unattended.
WARNING
FOR YOUR SAFETY:
For Outdoor Use Only! (outside any enclosure)
DANGER
If you smell gas -
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from
the appliance, immediately call your
gas supplier or your fire department.
Failure to follow these instructions
could result in fire or explosion
which could cause property damage,
personal injury or death.
GBC1707WT-C-OM-EF-F100

Table of Contents

Questions and Answers

  • C
    caldwellleviAug 16, 2025
    Why is Backyard Grill flame yellow or orange?
    • C
      Crystal JacksonAug 16, 2025
      If the flame on your Backyard Grill is yellow or orange, it might be due to residual manufacturing oils on a new burner. Try burning the grill for 15 minutes on high with the lid closed. Other possible causes include spider webs or insect nests in the venturi (clean the venturi), food residue or grease on the burners (clean the burners), or poor alignment of the valve to the burner/venturi tube (ensure proper engagement).
  • R
    Robert NelsonAug 19, 2025
    What to do if Backyard GBC1707WT-C has flare-up?
    • W
      Wendy NguyenAug 19, 2025
      Flare-ups in your Backyard Grill are often due to grease buildup, excess fat in the meat, or excessive cooking temperature. To resolve this: * Remove and clean all grill parts. * Trim fat from meat before grilling. * Adjust to a lower cooking temperature.
  • K
    Kara DunnAug 25, 2025
    What to do if Backyard Grill has persistent grease fire?
    • D
      Dawn BookerAug 26, 2025
      If your Backyard Grill has a persistent grease fire, it's likely due to grease trapped by food buildup around the burner system. Here's what to do: 1. Turn control knobs to “ OFF”. 2. If using LP, turn the LP gas tank valve to “CLOSED”. If using NG, turn the natural gas main valve to “OFF”. 3. Leave the lid closed and let the fire burn out. 4. After the grill cools, remove and clean all parts.
  • J
    Joshua CarpenterAug 28, 2025
    Why Backyard Grill flame goes out?
    • R
      Roger HarrisAug 28, 2025
      The flame on your Backyard Grill might be going out due to high or gusting winds or being low on LP Gas. Avoid using the grill in high winds. If you're low on LP Gas, exchange, refill, or replace the LP gas tank.
  • M
    Maria GutierrezAug 31, 2025
    What to do if Backyard Grill burner will not light with match?
    • D
      David SalinasAug 31, 2025
      If the burner on your Backyard Grill won't light with a match, it could be due to no gas flow, a low or empty LP gas tank, a gas leak, or other obstructions. If there's no gas flow, check if the LP gas tank is empty and exchange, refill, or replace it if needed. For NG, ensure the regulator and main line are securely attached and the main valve is open. Also, check for a gas leak. Furthermore, make sure the coupling nut and regulator are fully connected. Clear any obstruction of gas flow, check for bent or kinked hoses, reengage the burner to the valve if disengaged, clean the burner/venturi tube for spider webs or insect nests, and clean burner ports if clogged or blocked.
  • P
    Pamela MitchellSep 2, 2025
    Why Backyard GBC1707WT-C Grill has sudden drop in gas flow or reduced flame height?
    • J
      jyoungSep 3, 2025
      A sudden drop in gas flow or reduced flame height in your Backyard Grill can be due to several reasons. If you're using LP, you might be out of gas, so exchange, refill, or replace the LP gas tank. If you're using NG, there might be no main line pressure, so call your natural gas provider to inspect the line. Also, the overfilling prevention device may have been activated. To reset it, turn control knobs to “ OFF”, wait 30 seconds, and light the grill. If flames are still too low: 1. Turn control knob(s) “ OFF”. 2. Turn LP gas tank valve to “CLOSED”. 3. Disconnect regulator. 4. Turn control knobs to (HIGH). 5. Wait 1 minute. 6. Turn control knobs to “ OFF”. 7. Reconnect regulator and leak check connections, being careful not to fully open valve. 8. Light grill.
  • C
    curtisnathanSep 6, 2025
    What to do if Backyard Grill has flashback (fire in burner tube(s))?
    • N
      Nicole Johnston DDSSep 6, 2025
      If you experience flashback (fire in burner tubes) in your Backyard Grill, it's likely because the burner and/or burner/venturi tube are blocked. Clean the burners and/or burner/venturi tube(s).
  • K
    kguzmanSep 9, 2025
    Why Backyard GBC1707WT-C Grill lid is peeling?
    • S
      Sandra PerezSep 9, 2025
      If the inside of your Backyard Grill lid is peeling, it's likely due to grease buildup that has turned to carbon and is flaking off. Clean it thoroughly.
  • W
    wileyjenniferSep 12, 2025
    Why Backyard Grill has irregular flame pattern?
    • L
      Laura BowersSep 12, 2025
      An irregular flame pattern in your Backyard Grill, where the flame doesn't run the full length of the burner, is usually caused by clogged or blocked burner ports. Clean the burner ports to resolve this.
  • M
    Michelle RoseNov 21, 2025
    What to do if Backyard Grill burner will not light using ignitor?
    • C
      Christopher JonesNov 21, 2025
      If the burner on your Backyard Grill won't light using the ignitor, it could be due to several reasons. First, make sure the LP gas tank valve is open or the NG main valve is open. If using LP, ensure the regulator is securely attached to the LP gas tank. For NG, check that the regulator and NG main line are securely attached. Also, the LP gas tank might be low or empty, so exchange, refill, or replace it. A gas leak could also be the cause; in that case, turn off the gas, wait 5 minutes, and check for leaks. Other potential causes include wires or the electrode being covered with cooking residue (clean with rubbing alcohol), the electrode and burners being wet (wipe dry), a cracked or broken electrode (replace it), a loose or disconnected wire (reconnect or replace the electrode/wire asse...

Summary

Important Safeguards

General Safety Warnings and Precautions

General safety warnings and precautions for operating the grill, including location, fuel, and general adherence.

LP Gas Cylinder Handling and Storage

Specific safety rules for LP gas cylinders, including construction, storage, and safe handling practices.

Safe Operation and Clearance Requirements

Guidelines on safe grill operation, necessary clearances from structures, and general maintenance.

Operational Safety and Fire Prevention

Safety measures for grill operation, including unattended use, movement, fire extinguishing, and cooking practices.

Expanded View and Parts List

Component Diagram and Identification

Visual representation of all grill components with numbered labels for easy identification during assembly.

Assembly Instructions

Step-by-Step Assembly Guide

Detailed instructions for assembling the grill, including tips and required tools for a smooth process.

Gas Tank and Line Installation

Installing and Connecting LP Gas Tank

Procedures for safely inserting, securing, connecting, and disconnecting the LP gas tank.

Installing Natural Gas Line

Guidelines for connecting and disconnecting the natural gas line, requiring professional installation.

Operating Instructions

Checking for Gas Leaks

Method for performing a leak test on gas connections using soapy water before operating the grill.

Lighting and Operating Burners

Instructions on how to safely light the grill burners, including ignition procedures and troubleshooting.

Controlling Flare-ups and Fire Safety

Guidance on managing and minimizing flare-ups, including fire safety during cooking.

Cleaning and Care

Surface Cleaning Procedures

Methods for cleaning the exterior surfaces of the grill using mild detergents and brushes.

Main Burner Cleaning and Maintenance

Detailed steps for cleaning and maintaining the grill's main burners to ensure proper function.

Grill Storage and Protection

Instructions for preparing and storing the grill for periods of non-use, including protection from elements.

Limited Warranty

Warranty Terms and Conditions

Outlines the duration, coverage, exclusions, and responsibilities related to the product warranty.

Troubleshooting

Burner Ignition Problems

Addresses issues like burners not lighting with ignitor or match, and possible causes like gas flow or leaks.

Flame and Gas Flow Issues

Solutions for problems like sudden drop in gas flow, irregular flame patterns, or yellow/orange flames.

Flare-ups and Fire Safety Issues

Guidance on managing persistent grease fires, flashbacks, and other fire-related troubleshooting scenarios.

Backyard GBC1707WT-C Specifications

General IconGeneral
BrandBackyard
ModelGBC1707WT-C
CategoryGrill
LanguageEnglish

Related product manuals