Backyard GBC1305W - Page 9

Need help? 1.800.762.1142
Do not return to place of purchase.
Recipes
BlueRhino.com/recipes
Replacement Parts
parts.BlueRhino.com /
1.800.762.1142
PAGENO
9
 5SETHESIDEBURNEROFTHISAPPLIANCELIKEANORMALKITCHENRANGEFORBOILINGSAUTÏINGOR
frying.
 4OKEEPFOODFROMSTICKINGTOTHEGRIDSSPRAYORCOATWITHCOOKINGOILBEFORELIGHTING
 4OREDUCEFLAREUPSKEEPGRILLCLEANUSELEANCUTSOFMEATORTRIMFATANDAVOIDCOOKING
ONVERYHIGHTEMPERATURES
 0LACEDELICATEFOODSLIKEFISHANDVEGETABLESINALUMINUMFOILPOUCHESANDINDIRECTCOOKOR
PLACEONUPPERCOOKINGLEVELSWARMINGRACK
W WARNING: Never cover entire cooking area with aluminum foil.
 4OAVOIDLOSINGNATURALJUICESUSELONGHANDLEDTONGSORSPATULASINSTEADOFFORKSANDTURN
foods over just once during cooking.
9. 7HENDIRECTCOOKINGADJUSTYOURBURNERSTODIFFERENTLEVELSSOFOODSCANBEPREPAREDTO
DIFFERENTINTERNALTEMPERATURESINTHESAMETIMEFRAME
 7HENINDIRECTCOOKINGROASTSANDLARGERCUTSOFMEATPLACEMEATONTOAROASTINGRACK
INSIDEAHEAVYGAUGEMETALPAN0LACEPANOVERTHEUNLITBURNERS
 4RYWATERPANSTOREDUCEFLAREUPSANDCOOKJUICERMEATS"EFORESTARTINGGRILLREMOVE
COOKINGGRIDSANDPLACEAHEAVYDUTYSHALLOWPANDIRECTLYONHEATPLATES&ILLHALFWAYWITH
WATERFRUITJUICESOROTHERFLAVOREDLIQUIDS2EPLACECOOKINGGRIDSANDPOSITIONFOODOVER
THELOADEDPAN
 %NHANCEFOODFLAVORSBYUSINGWOODCHIPSINSMOKERBOXESORALUMINUMFOILPOUCHES
&OLLOWTHEWOODMANUFACTURERSINSTRUCTIONS
 2OTISSERIESGRILLBASKETSVERTICALPOULTRYHOLDERSANDOTHERACCESSORIESCANENHANCEYOUR
EXPERIENCESREDUCECOOKINGTIMESANDAIDINCLEANUP
 #LEANCOOKINGGRIDSANDRACKSAFTEREVERYUSEWITHAQUALITYGRILLBRUSHDESIGNEDFORYOUR
grid material.
 !FTEREVERYUSEALLOWGRILLTOCOOL4HENPROTECTCLEANCOOKINGGRIDSWITHALIGHTCOATOF
COOKINGOILEMPTYGREASEPANWIPEOUTSIDESURFACESWITHASUITABLEKITCHENCLEANERAND
PROTECTSURFACESWITHAQUALITYCOVERTHATPROPERLYFITSYOURGRILL
 7ATCHBARBECUETHEMED46SHOWSORPURCHASERELATEDBARBECUECOOKBOOKSTOLEARNMORE
INTERESTINGTIPSLIKEn
A gas grill is ideal for reheating leftover pizza. Set burners on low and place pizza slices
directly on preheated cooking grid. Close lid and cook until cheese starts to bubble.
Cleaning and Care
W CAUTION:
1. All cleaning and maintenance should be done when grill is cool
and with the fuel supply disconnected.
2. DO NOT clean any grill part in a self cleaning oven. The extreme
heat will damage the finish.
3. Do not enlarge valve orifices or burner ports when cleaning the
valves or burners.
Notices
1. This grill should be thoroughly cleaned and inspected on a regular basis.
2. Abrasive cleaners will damage this product.
3. Never use oven cleaner to clean any part of grill.
Before Each Use:
 +EEPTHEGRILLAREACLEANANDFREEFROMANY
combustible materials, gasoline, and other
FLAMMABLEVAPORSANDLIQUIDS
 $ONOTOBSTRUCTTHEFLOWOFTHECOMBUSTIONOF,0
and the ventilation air.
 +EEPTHEVENTILATIONOPENINGSOFTHE,0GASTANK
area free and clear from debris.
 6ISUALLYCHECKTHEBURNERFLAMESTOMAKESURE
YOURGRILLISWORKINGPROPERLY&IGURE
 3EESECTIONSBELOWFORPROPERCLEANING
instructions.
 Check and clean the burner/venturi tubes for
insects and insect nests. A clogged tube can lead
to a fire beneath the grill.
Cleaning Surfaces
 7IPESURFACESCLEANWITHMILDDISHWASHING
DETERGENTORBAKINGSODAMIXEDWITHWATER
 &ORSTUBBORNSURFACESUSEACITRUSBASED
degreaser and a nylon scrubbing brush.
 2INSECLEANWITHWATER
 !LLOWTOAIRDRY
Cleaning Main Burners
 Turn control knobs to “ /&&vAND,0GASTANK
VALVETOh#,/3%$v
 $ISCONNECT,0GASTANKPERh$ISCONNECT,0'AS
4ANKvINSTRUCTIONS
Operating Instructions
Checking for Leaks
Burner Connections
 Make sure the regulator valve and hose
connections are securely fastened to the burner
and the tank.
6ISUALLYCHECKTHECONNECTIONBETWEENTHEBURNER
VENTURIPIPEANDORIFICE-AKESURETHEBURNER
VENTURIPIPEFITSOVERTHEORIFICE
W WARNING: Failure to inspect this
connection or follow these instructions
could cause a fire or an explosion
which can cause death, serious bodily
injury or damage to property.
 0LEASEREFERTODIAGRAMFORPROPERINSTALLATION
&IGURES
 )FTHEBURNERPIPEDOESNOTRESTFLUSHTOTHEORIFICE
PLEASECONTACTFORASSISTANCE
Tank/Gas Line Connection
 -AKEOZOFLEAKSOLUTIONBYMIXINGONEPART
LIQUIDDISHWASHINGSOAPWITHTHREEPARTSWATER
 Make sure control knobs are “
/&&vPOSITION
&IGURE
 #ONNECT,0GASTANKPERh)NSTALLING,0'AS4ANKv
section.
 4URN,0GASTANKVALVETOh/0%.v
 3POONLEAKCHECKSOLUTIONATALLh8vLOCATIONS
&IGURESAND
a. )FANYBUBBLESAPPEARTURN,0GASTANKVALVE
TOh#,/3%$vRECONNECTANDRETEST
b. If you continue to see bubbles after
SEVERALATTEMPTSTURN,0GASTANKVALVETO
h#,/3%$vANDDISCONNECT,0GASTANKPER
h$ISCONNECT,0'AS4ANKvINSTRUCTIONSAND
CONTACTFORASSISTANCE
c. )FNOBUBBLESAPPEARAFTERONEMINUTETURN
,0GASTANKVALVETOh#,/3%$vWIPEAWAY
SOLUTIONANDPROCEED
Operating Main Burners
First Use
 -AKESUREALLLABELSPACKAGINGANDPROTECTIVE
films have been removed from the grill.
 Remove manufacturing oils before cooking on this
GRILLFORTHEFIRSTTIMEBYOPERATINGTHEGRILLFORAT
LEASTMINUTESON
()'(WITHTHELIDCLOSED
4HISWILLhHEATCLEANvTHEINTERNALPARTSAND
DISSIPATEODORS
Lighting Instructions
W CAUTIOn: Keep outdoor gas cooking
appliance area clear and free from
combustible materials, gasoline and
other flammable vapors and liquids.
W CAUTIOn: Do not obstruct the flow of
combustion and ventilation air.
W CAUTIOn: Check and clean burner/venturi tubes for insects and insect
nests. A clogged tube can lead to a fire beneath the grill.
W CAUTIOn: Attempting to light the burner with the lid closed may cause
an explosion.
 /PENLID
 -AKESURETHEREARENOOBSTRUCTIONSOFAIRFLOWTOTHEBURNERS3PIDERSANDINSECTSCANNEST
WITHINANDCLOGTHEBURNERVENTURITUBEATTHEORIFICE!CLOGGEDBURNERTUBECANLEADTOA
FIREBENEATHTHEAPPLIANCE
 All control knobs must be in the “
/&&vPOSITION&IGURE
 #ONNECT,0GASTANKPERh)NSTALLING,0'AS4ANKvSECTION
 4URN,0GASTANKVALVETOh/0%.v
 Select burner to light. Push and turn control knob to
()'(
 Press the
IGNITERBUTTONREPEATEDLYTOTIMESTOLIGHTBURNER
 )FIGNITIONDOESNOTOCCURINSECONDSTURNBURNERCONTROLKNOBh
/&&vWAITMINUTES
ANDREPEATLIGHTINGPROCEDURE
9. )FIGNITERDOESNOTLIGHTBURNERUSEALITMATCHSECUREDWITHTHELIGHTINGRODPROVIDEDTO
LIGHTBURNERSMANUALLY!CCESSTHEBURNERSTHROUGHTHECOOKINGGRIDANDHEATPLATES
0OSITIONTHELITMATCHNEARSIDEOFTHEBURNER&IGURE
Important:!LWAYSUSETHELIGHTINGRODPROVIDEDWHENLIGHTINGBURNERSWITHAMATCH
 !FTERLIGHTINGOBSERVETHEBURNERFLAMEMAKESUREALLBURNERPORTSARELITANDFLAMEHEIGHT
MATCHESILLUSTRATION&IGURE
Note%ACHBURNERLIGHTSINDEPENDENTLYREPEATSTEPSFORTHEOTHERBURNERS
W CAUTION: If burner flame goes out during operation, immediately turn
the control knobs to the
(OFF) position, turn the LP gas tank valve
to “CLOSED” and open lid to let the gas clear for 5 minutes before re-
lighting.
Turning Off
 4URN,0GASTANKVALVETOh#,/3%$v
 4URNALLCONTROLKNOBSCLOCKWISETOTHEh
/&&vPOSITION
Note: !hPOOFvSOUNDISNORMALASTHELASTOFTHE,0GASISBURNED
 $ISCONNECT,0GASTANKPERh$ISCONNECT,0'AS4ANKvINSTRUCTIONS
Direct Cooking
W CAUTION: Do not leave grill unattended while preheating, cooking or burning
off food residue on
(HIGH). If grill has not been cleaned, a grease fire can
occur.
Cooking directly over lit burners is ideal for searing in juices and grilling food requiring less than
MINUTESOFGRILLINGTIMESUCHASSTEAKSHAMBURGERSHOTDOGSCHICKENPARTSVEGETABLES
and fruit.
 /PENLIDANDIGNITETHEDESIREDBURNERSPERh,IGHTING)NSTRUCTIONSvSECTION
 #LOSELIDANDPREHEATGRILLON
()'(
 7EARPROTECTIVEGLOVESANDUSELONGHANDLETONGSTOPLACEFOODONTOCOOKINGGRIDSABOVE
the lit burners.
 Adjust controls to desired flame height.
 7ITHLIDOPENORCLOSEDCOOKUNTILDESIREDINTERNALFOODTEMPERATURESAREACHIEVED
 4URNGRILL/&&PERh4URNING/FFvINSTRUCTIONS
&ORMORETIPSONDIRECTCOOKINGPLEASESEEh4IPSFOR"ETTER#OOKOUTSAND,ONGER'RILL,IFEv
Indirect Cooking
W Caution: Do not leave grill unattended while preheating, cooking or
burning off food residue on
(HIGH). If grill has not been cleaned, a
grease fire can occur.
.OTCOOKINGDIRECTLYOVERLITBURNERSISIDEALFORSLOWCOOKINGANDFOODSREQUIRINGMORETHAN
MINUTESSUCHASMOSTROASTSLOINSCHOPSWHOLECHICKENSTURKEYFISHANDBAKEDGOODS
 /PENLIDANDIGNITETHEDESIREDBURNERSPERh,IGHTING)NSTRUCTIONSvSECTION
 #LOSELIDANDPREHEATGRILLON
()'(
 7EARPROTECTIVEGLOVESANDUSELONGHANDLETONGSTOPLACEFOODONTOCOOKINGGRIDSABOVE
the un-lit burners.
 Adjust controls to desired flame height.
 7ITHLIDCLOSEDCOOKUNTILDESIREDINTERNALFOODTEMPERATURESAREACHIEVED
 4URNGRILL/&&PERh4URNING/FFvINSTRUCTIONS
&ORMORETIPSONINDIRECTCOOKINGPLEASESEEh4IPSFOR"ETTER#OOKOUTSAND,ONGER'RILL,IFEv
Controlling Flare-ups
W CAUTION: Putting out grease fires by closing the lid is not possible.
1. If a grease fire develops, turn knobs “
OFF” and LP gas tank valve
“CLOSED.” Do not use water on a grease fire. This can cause the
grease to splatter and could result in serious burns, bodily harm
or other damage.
2. Do not leave grill unattended while preheating or burning off food
residue on
(HIGH). If grill has not been cleaned, a grease fire can
occur that may damage the product.
W WARNING: When cooking, fire extinguishing materials shall be
readily accessible. In the event of an oil/grease fire. Use type BC dry
chemical fire extinguisher or smother with dirt, sand or baking soda.
Do not attempt to extinguish with water.
&LAREUPSAREAPARTOFCOOKINGMEATSONAGRILLANDADDSTOTHEUNIQUEFLAVOROFGRILLING
Excessive flare-ups can over-cook your food and cause a dangerous situation for you
and your grill.
Important: %XCESSIVEFLAREUPSRESULTFROMTHEBUILDUPOFGREASEINTHEBOTTOMOFYOURGRILL
If a grease fire occurs, close the turn AND lid the control knob(s) to “
/&&vUNTILTHEGREASE
BURNSOUT5SECAUTIONWHENOPENINGTHELIDASSUDDENFLAREUPSMAYOCCUR
)FEXCESSIVEFLAREUPSOCCURDO NOTPOURWATERONTOTHEFLAMES
Minimize Flare-ups:
 4RIMEXCESSFATFROMMEATSPRIORTOCOOKING
 Cook high fat contents meats on
,/7SETTINGORINDIRECTLY
 %NSURETHATYOURGRILLISONAHARDLEVELNONCOMBUSTIBLESURFACEANDTHEGREASEIS
ALLOWEDTODRAININTOGREASECUP
Tips for Better Cookouts and Longer Grill Life
 &ORGREATRECIPESANDTIPSVISITRECIPESUNIFLAMECOM
 &ORFOODSAFETYTIPSVISITHTTPWWWFSISUSDAGOV&ACT?3HEETS"ARBECUE?&OOD?3AFETY
 5SETHEUPPERCOOKINGGRIDWARMINGRACKFORKEEPINGCOOKEDFOODWARMTOASTINGBREADS
ORCOOKINGDELICATEFOODSINALUMINUMFOILPOUCHES
&IGURE
Burner Flame Conditions
Use this chart check to see if your
burners need to be cleaned.
1-2 in. /
25.4 - 50.8 mm
1-2 in. /
25.4 - 50.8 mm
Normal:3OFTBLUEFLAMESWITHYELLOW
TIPSBETWEENININHIGHT
Needs Cleaning:.OISYWITHHARDBLUE
flames.
Has to be cleaned or replaced: Wavy
WITHYELLOWFLAMES