Bad Boy 1500G User Manual

STARTING/OPERATING PROCEDURES
Choke
 •ChokeLeverisforuseinlowtemperaturestartingsituations.DonotdrivetheUTVwiththechokeactivated.
 •Thisvehicleisequippedwithasafetyprotectionsystem—tostarttheenginebrakemustbeapplied.
 •TheUTVwillstartinanygearwhenbrakeisapplied.Keepthisinmindwhenstartingtopreventinjuryfrom
movement of the vehicle.
 •TheUTVfuelsystemissensitiveandwillnotallowthevehicletostartifmorethan1/8ththrottleisapplied
 whencranking.
 •Forcoldweatherstarting,itisbesttostartthemachineinneutral,withnothrottleappliedandchokefullyengaged.
Brake Pedal
 •Beforeeachtrip,checkthefunctionofthebrakepedal.Alsocheckforsufcientbrakeuidinthereservoir.
 •Attention:Irregularitiesofthebrakessuchasleaksandpoorperformanceshouldonlybedealtwithbyan
 authorizeddealer.ThebrakeuidlevelmustbeabovetheMINmark.AlwaysuseDOT#4brakeuid.
Shift Lever
 L:Hightorqueuse(advancegear)
 H:Normaluse(drivinggear)
 N:Parkinguse(neutral)
R: Reverse use
Shift Lever Instructions:
 •EngagethebrakeandmovetheshiftleverfromNtoH,LorR(Lshiftisusedforroughsurfaces)
 *WhenShiftingHtoLoranygear/directionthevehiclemustbeatacompletestop.
Notice: Operating the shift lever when vehicle is moving can be hazardous and can cause damage to the vehicles
transmission. This is strictly prohibited. Always wait until the vehicle comes to a complete stop.
Do not operate the UTV at high speed in reverse under any circumstances.
2WD/4WD Select Lever
 •The2WD/4WDselectleverisusedforchangingtheenginepowersuppliedtothewheels.Youcanselect2WDor
4WD for your preference according to different surface conditions.
 •2WD:Engagestheenginepowertotherearwheelsonly.Thisismainlyusedfornormalriding.
 •4WD:Engagestheenginepowertobothfrontandrearwheelswithdifferentialfunction.Thereisalimitedslipgear
assembly inside the front differential that can engage the right and left front wheels at different speeds. This
provides much more traction than 2WD and should be used when riding on wet, slippery, or loose surfaces.
GENERAL MAINTENANCE
Recoil Starter
In case the vehicle does not start with the electric starter, the emergency recoil starter can be used to start the engine. To use
therecoilstartermakesuretheheadlightsareswitchedoff,shifttoneutral(N),settheparkbrakeandgripthestarterrope-
handle, which is on the engine magneto cover. Pull the rope until you feel the starter engage. Pull the rope forcefully to start
the engine. At the moment the engine starts, be sure to return the starter rope to its prior normal position.
Tires
The vehicle is equipped with tubeless tires. Tubeless tires should never be repaired. Damaged tires must be replaced.
Yourauthorizeddealershouldonlyreplacetubelesstires.Sincethetirepressureinuencesthedrivingability,themandatory
tire pressure should always be maintained. You should determine outer damages of tires. The suggested minimum profile
depth is 3mm; replace the tire immediately if below 3mm. Tire pressure: 12 PSI
PAGE 6

Bad Boy 1500G Specifications

General

Brand	Bad Boy
Model	1500G
Category	Utility Vehicle
Language	English