Bosch BSH Dishwasher User Manual

1
IMPORTANT
• The dishwasher drain hose must be installed
with a portion of it at least 20” (508mm) off the
cabinet floor; otherwise the dishwasher may not
drain properly.
• This dishwasher is intended for residential use
only, and should not be used in commercial
food service establishments.
• NEW INSTALLATION - If the dishwasher is a
new installation, most of the work must be done
before the dishwasher is moved into place.
• REPLACEMENT - If the dishwasher is
replacing another dishwasher, check
the existing dishwasher connections for
compatibility with the new dishwasher, and
replace parts as necessary.
• This appliance has been found to be in
compliance with CAN/CSA-C22.2 No. 167/UL
749. It is the responsibility of the owner and the
installer to determine if additional requirements
and standards apply in specific installations.
Inspect the Dishwasher
After unpacking the dishwasher and prior to
installation, thoroughly inspect the dishwasher for
possible freight or cosmetic damage. Report any
damage immediately. Cosmetic defects must be
reported within 30 days of installation.
NOTE: Do not discard any bags or items that
come with the original package until after the entire
installation has been completed.
The dishwasher must be installed by a qualified
service technician or installer.
• In addition to these instructions, the dishwasher
shall be installed to meet all electrical and
plumbing codes and ordinances (both national
and local).
Read these installation instructions completely
and follow them carefully. They will save you time
and effort and help to ensure safety and optimum
dishwasher performance.
To avoid possible injury or property damage,
OBSERVE ALL WARNINGS AND CAUTIONS.
These instructions are intended for use by
qualified installers only.
Important Safety Instructions
If the dishwasher is installed in a location
that experiences freezing temperatures (e.g.,
in a holiday home), you must drain all the
water from the dishwasher’s interior. Water
system ruptures that occur as a result of
freezing are NOT COVERED BY WARRANTY.
WARNING
Dishwasher Installation Instructions
English/French/Spanish
IMPORTANT INSTRUCTIONS ............................... 1
Tools Needed ..........................................................
2
Materials Needed ...................................................
2
Materials Supplied ..................................................
3
Enclosure Preparation ............................................
5
Electrical Preparation .............................................
6
Plumbing Preparation ..........................................
7-8
Dishwasher Preparation ......................................
8-9
Door Panel Installation .........................................
10
Table of Contents
Read these Installation Instructions completely and follow them carefully.
Placing the Dishwasher ...................................10-11
Securing the Dishwasher ......................................
11
Drain Hose Connection ...................................
11-12
Hot Water Connection .....................................
12-13
Electrical Connection .......................................
13-14
Door Tension Adjustment ......................................
14
Base and Toe Panel ..............................................
15
Final Instructions ..................................................
15
Customer Service .................................................
16
9000121319 REV B · 01/06

Bosch BSH Dishwasher Specifications

General

Brand	Bosch
Model	BSH Dishwasher
Category	Dishwasher
Language	English

Summary

Important Safety Instructions

Inspect the Dishwasher

Inspect the dishwasher for possible freight or cosmetic damage after unpacking. Report any damage immediately.

Materials Supplied

Accessory Parts Supplied

Lists accessory parts supplied with the dishwasher, such as manuals and installation kits.

Dishwasher Installation Kit

Details the components included in the dishwasher installation kit, including various screws and fittings.

Integrated Door Panel Installation Kit

Describes the kit for installing a custom wood door panel on select dishwashers.

Toe Panel Installation Kit

Details the kit for installing a special noise-reducing toe panel on select dishwasher models.

Enclosure Preparation

Enclosure Preparation Steps

Select location, ensure enclosure is square, and check corner clearance for door opening.

Electrical Preparation

Electrical Supply Requirements

Details the electrical supply requirements, including voltage, frequency, circuit rating, and wire gauge.

Plumbing Preparation

Hot Water Supply Requirements

Specifies hot water temperature, pressure, and the need for an accessible shut-off valve.

Hot Water Supply Plumbing

Discusses connecting the hot water supply line using braided hose or copper tubing with a 90° elbow fitting.

Dishwasher Preparation

Drain Plumbing Options

Covers connecting the drain hose to under-sink plumbing, air gaps, and disposer connections.

Installing Countertop Mounting Brackets

Details methods for installing mounting brackets for top or side mount on countertops.

Removing the Toe Panel

Explains how to remove the metal toe panel or plastic base access panel from the dishwasher.

Installing the 90° Elbow Fitting

Instructions on installing the separately purchased 90° elbow fitting for the hot water supply line.

Junction Box Preparation

Steps for preparing the junction box, including removing the cover and strain relief plate.

Door Panel Installation

Accessory Panel Installation Kits

Information on kits for installing custom panels, including dimensions for integrated door panels.

Fully Integrated Models

Explains custom door panel options for fully integrated models and door spring tension.

Placing the Dishwasher

Positioning Dishwasher in Enclosure

Guides on aligning supply lines and cable, positioning the dishwasher, and ensuring it stays in channels.

Leveling the Dishwasher

Instructions on adjusting front and rear levelers, and using shims if needed for proper leveling.

Securing the Dishwasher

Mounting Bracket Installation

Instructions on driving screws through mounting brackets for top or side mount securing.

Locking Front Leg Levelers

How to lock the front leg levelers in place using leg leveler locking screws after installation.

Drain Hose Connection/Hot Water Connection

Connecting the Drain Hose to Household Plumbing

Describes four ways to connect the drain hose to the household drain plumbing system.

Hot Water Connection

Provides a warning about hot water and mentions connecting the supply line with braided hose or copper tubing.

Hot Water Connection/Electrical Connection

Copper Tubing Water Connection

Cautions about soldering near the water inlet valve and sealing connections for copper tubing.

Electrical Connection Grounding

Details grounding instructions for the dishwasher, emphasizing compliance with electrical codes.

Electrical Connection

Electrical Wire Connections

Instructions for connecting dishwasher wires to power supply wires using wire nuts, ensuring secure connections.

Door Tension Adjustment

Guidance on adjusting door spring tension for custom door panels on fully integrated models.

Toe Panel Installation

Instructions for installing the toe panel using screws from the dishwasher installation kit.

Base and Toe Panel

Plastic Base Access Panel Installation

Steps for installing the plastic base access panel and attaching the metal toe panel.

Final Instructions

Steps to energize the power supply and run a test cycle, plus troubleshooting advice.

Customer Service

Troubleshooting and Service

Guidance on seeking service, contacting customer support, and required information for assistance.