Bradford White BRUTE DELUXE BMT2H User Manual

WARNING
If the information in this manual is not
followed exactly, a fire or explosion may
result causing property damage, personal
injury or loss of life.
Do not store or use gasoline or other
flammable vapors and liquids in the vicinity of
this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Immediately call your gas supplier from
a nearby phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call
the fire department.
Installation and service must be performed
by a qualified installer, service agency, or gas
supplier.
Installation and Operation Instructions Document 1244
H2343200-
FOR YOUR SAFETY: This product must be installed and serviced by a professional service technician,
qualified in hot water boiler installation and maintenance. Improper installation and/or operation could
create carbon monoxide gas in flue gases which could cause serious injury, property damage, or
death. Improper installation and/or operation will void the warranty. For indoor installations, as an
additional measure of safety, Bradford White strongly recommends installation of suitable Carbon
Monoxide detectors in the vicinity of this appliance and in any adjacent occupied spaces.
AVERTISSEMENT
Assurez-vous de bien suivres les instructions
données dans cette notice pour réduire au
minimum le risque d’incendie ou d’explosion ou
pour éviter tout dommage matériel, toute blessure
ou la mort.
Ne pas entreposer ni utiliser d’essence ni d’autres
vapeurs ou liquides inflammables dans le voisinage
de cet appareil ou de tout autre appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d’allumer d’appareils.
• Ne touchez à aucun interrupteur. Ne pas vous
servir des téléphones dansle bâtiment où vous
trouvez.
• Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions
du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de
gaz, appelez le sservice des incendies.
L’installation et l’entretien doivent être assurés par
un installateur ou un service d’entretien qualifié ou
par le fournisseur de gaz.
Installation and Operation
Instructions for
BRUTE DELUXE
Hydronic Boiler
Model BMT2H
Water Heater
Model BMT2V
Sizes 200, 300, 400
238-49221-00A REV 4/11

Bradford White BRUTE DELUXE BMT2H Specifications

General

Category	Water Heater
Brand	Bradford White
Model	BRUTE DELUXE BMT2H
Type	Tank
Fuel Type	Natural Gas
Warranty	6 years

Summary

Venting and Combustion Air

Combustion Air

Requirements for providing combustion and ventilation air for the appliance.

Combustion Air From Room

Intake Combustion Air

Venting

Information on different vent categories and system requirements.

Category I Vent

Common Venting Systems

Category III Vent

Locating Vent & Combustion Air Terminals

Common Vent Test - Boilers

Gas Supply and Piping

Gas Supply and Piping

Instructions for connecting and sizing gas supply lines.

Water Connections — Brute Deluxe Boiler

Heating System Piping: Hot Supply Connections — Boiler

Details for connecting hot supply piping to the boiler.

Cold Water Make-Up — Boiler

Freeze Protection — Boiler

Water Connections — Brute Deluxe Water Heater

Water System Piping — Water Heater

Guidance for hot water piping connections to the water heater.

Hot Water Supply Piping — Water Heater

Freeze Protection - Water Heater

Electrical Connections

Main Power

Instructions for connecting the main 120-volt power supply.

Field Wiring

Details on wiring field-installed components like pumps and interlocks.

Operating Instructions

Filling the Boiler System

Step-by-step procedure for filling the boiler system with water.

Operating Temperature Control

Sequence of Operation

Describes the operational steps from ignition to shutdown.

Ignition Control Reaction to Air Flow / Blocked Vent Pressure Switch

How the ignition control responds to air flow and vent status.

Operating the Burner and Set-Up

Procedures for burner operation and initial setup.

Set-Up for 0 to 2500 Feet Altitude

High Altitude Adjustment and Set-Up

Shutting Down the Brute Deluxe

To Restart the Brute Deluxe

Maintenance

System Maintenance

Routine maintenance tasks for the water circulation system.

Appliance Maintenance and Component Description

Overview of maintenance for appliance components and part descriptions.

Burners

Gas Valves

Manual Reset High Limit Control

Ignition Control

Ignitor

Flow Switch

Heat Exchanger Coil

Procedures for inspecting and cleaning the heat exchanger.

Trouble Shooting

Resolving Lockouts

Identifies common causes and solutions for appliance lockouts.

Delayed Ignition — Possible Causes

Short Cycling - Boiler

Explains causes and remedies for boiler short cycling.

Short Cycling - Water Heater

Explains causes and remedies for water heater short cycling.

High Gas Consumption

Addresses causes of high gas consumption and efficiency adjustments.