BraunAbility Foldout Ramp - Maintenance and Lubrication Schedule

Page 6
Perform all procedures listed in previous section also
6 Months
Power Fold Ramps:
5DPSÁDSH[WHQVLRQFKDLQ
Remove ramp housing cover/rear vertical panel
and inspect:
7RSPRXQWEUDFNHWEROWVIRUVHFXUHPHQW
(loose or missing)
0RWRUPRXQWLQJEROWVIRUVHFXUHPHQWORRVH
or missing)
5DPSIROGDUPVHFXUHPHQWFROODUDQG
mounting screws)
0LFURVZLWFKHVVHFXUHPHQWDQGDGMXVWPHQW
0LFURVZLWFKZLUHVDQGWHUPLQDOVIRUVHFXUH-
ment or damage
0DJQHWLFVZLWFKRSWLRQDO
Inspect power source: Vehicle battery, 50
ampere fuse, vehicle engine compartment fuse
block and driver side under dash-mounted fuse
block.
Inspect kneel actuator assembly for:
$FWXDWRUPRXQWLQJSLQVHFXUHPHQWPLFUR-
switch activation block)
,QVSHFWFKDLQIRUPLVDOLJQPHQWZHDURU
damage
,QVSHFWFKDLQPDVWHUOLQNVIRUVHFXUHPHQW
,QVSHFWFKDLQLGOHUSXOOH\IRUVHFXUHPHQW
wear, damage or misalignment
,QVSHFWHOHFWULFDOKDUQHVVHVIRUSRVLWLYH
connections, proper routing, wear or other
damage
.QHHOPLFURVZLWFKHVVHFXUHPHQWZHDURU
other damage
Kneel electrical override
Kneel assembly chain
Lubricate with Anti-Seize (14 oz. caulk tube
available per Braun part no. 24710)
Resecure, adjust microswitches, replace dam-
aged parts or otherwise correct as needed.
Note: See 2008 Foldout Ramp Exploded views
on pages 19B-20B, 23A-24A and 23B-24B.
Resecure, repair or replace
Realign, resecure, replace damaged parts or
otherwise correct as needed. Note: See Kneel
Actuator Assembly exploded view on page 27.
Check operation
Lubricate with Anti-Seize (14 oz. caulk tube
available per Braun part no. 24710)
MAINTENANCE and SERVICE
Maintenance and Lubrication Schedule
Consecutive
3 Month
Intervals
Repeat all previously listed inspection, lubrica-
tion and maintenance procedures at 3 month
intervals.