49
TROUBLESHOOTING CHARTS
ENGINE WILL NOT START
3. Discharged battery.
- Have the battery charged or replaced by an authorized Rotax Jet Propulsion dealer, repair
shop, or person of your own choosing for maintenance, repair, or replacement.
4. Battery connections, corroded or loose.
- Contact an authorized Rotax Jet Propulsion dealer, repair shop, or person of your own
choosing for maintenance, repair, or replacement.
5. Water flooded engine.
- Contact an authorized Rotax Jet Propulsion dealer, repair shop, or person of your own
choosing for maintenance, repair, or replacement.
6. Obstructed jet pump.
- Try to clean. Otherwise, refer to an authorized Rotax Jet Propulsion dealer.
7. Faulty engine management system.
- Seek service from an authorized Rotax Jet Propulsion dealer, repair shop, or person of
your own choosing for maintenance, repair, or replacement. Please refer to the US EPA
EMISSION-RELATED WARRANTY contained herein for information about warranty claims.
ENGINE TURNS SLOWLY
1. Loose battery cable connections.
- Check/clean/tighten.
2. Discharged or weak battery.
- Have the battery charged or replaced by an authorized Rotax Jet Propulsion dealer.
3. Bad grounds.
- Refer to an authorized Rotax Jet Propulsion dealer.
4. Worn starter or related parts.
- Refer to an authorized ROTAX Jet Propulsion dealer.
ENGINE TURNS NORMALLY BUT WILL NOT START
1. Fuel tank empty or water contaminated.
- Refill or siphon and fill with fresh fuel.
2. Fouled/defective spark plugs.
- Replace.
3. Burnt fuse.
- Check fuse(s). See an authorized Rotax Jet Propulsion dealer, repair shop, or person of
your own choosing for maintenance, repair, or replacement if problem is repetitive.
4. Water flooded engine.
- Refer to WATER-FLOODED ENGINE in SPECIAL PROCEDURES.
5. Engine management System Fault Detected (Check If Engine Pilot Lamp Is On).
- Seek service from an authorized Rotax Jet Propulsion dealer, repair shop, or person of
your own choosing for maintenance, repair, or replacement. Please refer to the US EPA
EMISSION-RELATED WARRANTY contained herein for information about warranty claims.
To Next Page
Loading...
