Bukh DV24 RME User Manual

OPERATING MANUAL FOR BUKH DV24RME LIFEBOAT ENGINES
009W4826-R11 - 13 -
RECOMMENDED MAINTENANCE AND CHECK LIST FOR BUKH LIFEBOAT ENGINES
CHECK RECTIFY IF
NEEDED
1. Tightness of connections through hull:
W
E
E
K
L
Y
M
O
N
T
H
L
Y
Y
E
A
R
L
Y
EVERY
5
YEARS
1.1 stern tube hull connection change sealing X
1.2. keel-cooling pipes hull connection change sealing X
1.3 spray pump hull connection change sealing X
2. Check of lubricating oil:
2.1 a engine change oil
-
X X
2.1.b engine check oil level
-
X
2.2.a gearbox change oil - X
2.2.b gearbox check oil level
-
X
2.3 sealbox for spraypump refill the oillevel renew if leaking- X
2.4 lubricating oil filter change
-
X
3. Check of cooling watersystem:
3.1 system system to be full fill up X
3.2 anti freeze liquid check for minus
25°C.
refill anti freeze liquid X
3.3 cooling water connections tightness for leaks renew if leaking X
3.4 condition of rubber hoses cracks and leaks renew X
3.5 retightened clamping bands
- -
3.6 V-belt for cooling water pump adjust or renew - X
3.7 thermostat renew after 5 years - X
4. Check of fuel system:
4.1 supply line clean water/fuel
separator and check
line bends
repair if damaged or
renew
X
4.2 fuel tank drain for water - X
4.3 fuel filter change - X
4.4 return line check for bends &
damages
repair if damaged or
renew
X
5. Check of remote control cables:
5.1 cables check easy operation
and stroke sufficient
adjust cables X
6. Check of propeller shaft arrangement:
6.1 rear stern tube bearing check clearance for
bearing insert
renew insert X
6.2 sufficient water flow to rear stern tube bearing check that water
holes in bearing
housing are not
blocked
clean holes X
6.3 alignment of gear flange and prop.shaft flange alignment to be within
0.05- 0.01mm
realign the engine X
6.4 stuffing box seals tightness renew all three seals X
6.5 condition of rubber tube for stuffing box cracks renew X
6.6 Out-Board gearoil. oillevel refill X
6.7 propeller check size and
condition
renew if damaged X
7. Starting of the engine:
7.1 start with electrical start engine start within
2 minutes
if malfunctions -the
engine must be ser-
viced by a mechanic
X
7.2 start with handstart same same X
7.3 start with other optional starting system if fitted same same X
7.4 starting instruction if it is readable change if damaged X

Bukh DV24 RME Specifications

General

Brand	Bukh
Model	DV24 RME
Category	Engine
Language	English