Carpigiani K 3 User’s guide
This manual is for the exclusive use of licensees and employees of McDonald’s Systems Inc Page 29 of 63
Version 5: October 2012
4. DAILY OPENING PROCEDURES
Check that pasteurisation cycle has been successfully completed and the display indicates the message "PAST. END",
followed by the time and day of its completion.
If the pasteurisation cycle wasn’t completed successfully ,the machine will be locked out. Check the reason
reading the alarm messages and press
in order to reset the message on the display. Press STOP then
PROD. button to run pasteurisation cycle manually. Once the pasteurisation cycle is completed successfully, the
lock out resets automatically and the machine is ready to go in production. No product can be dispensed during
the pasteurisation cycle (approximately three hours).
4.1 MILK SHAKE SIDE
Make sure your hands are clean and sanitized before performing the following procedures.
4.1.1 SANITIZING THE DOOR AREA:
a) Fill an empty pail with McD Sanitizer prepared in water at 70-90°F
(21-32°C) (1 packet in 2-1/2 gallons (9-1/2 litres) of water = 100
PPM) and mix the powder.
b) Immerse the brushes in the sanitising solution and wipe several
times the dispensing area of the door, the small cover underneath
the door, the dispensing hole, the area above the same door and
everywhere inside the door.
c) Spray the sanitising solution on the dispensing part, on the door
area, underneath the piston cover and all around the door.
d) Clean the external parts of the machine with a clean and sanitizing
towel.
4.1.2 STARTING UP THE MACHINE:
The machine is in STOP function. Press the PROD button in order to start it up. The led will blink and
the starting up process is carried out for 15 minutes. During this time, you CANNOT dispense the
Shake. When “PROD” LED stays STILL, the Milk Shake is ready to serve.
WARNING
Do not keep any syrup line empty. In case you are using only 3 syrup flavours, you must close the hole
of the front lid using the tap delivered with the accessories as indicated in sect. 6.4.2.1 of the user’s
manual.
S
A
N
I
T
I
Z
E
R
To Next Page
Loading...