Carrier 48TF004-014 - Wiring Diagrams Manual

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.
PC 111 Catalog No. 534-80110 Printed in U.S.A. Form 48T-1W Pg 1 7-03 Replaces: 48TF-1W
Book 1 4
Ta b 1 a 6 a
Wiring Diagrams
DIAGRAM INDEX
*Low NOx/California compliant units.
OPTION AND ACCESSORY WIRING
*Durablade Economizer was a factory-installed option (FIOP) until 2/15/02, it is currently available only as a field-installed accessory.
†EconoMi$er wiring in Fig. 25 is generic (for units produced from 5/99 – 2/02) with the exception of the way the power exhaust switch is wired.
Refer to Fig. 28 and 29 for more detailed power exhaust switch information.
**Can be factory-installed or field-installed; wiring is the same for both.
UNIT LABEL DIAGRAM
Unit 48TF,TM Voltage-Phase-Hertz Type Label Diagram Figure No.
004,005
208/230-1-60 Schematic/Component Arrangement 50DK508460 1
208/230-3-60 Schematic/Component Arrangement 50DK508515 2
460-3-60 Schematic/Component Arrangement 50DK508518 3
575-3-60 Schematic/Component Arrangement 50DK508522 4
208/230-3-60* Schematic/Component Arrangement 50DK509082 5
460-3-60* Schematic/Component Arrangement 50DK509084 6
006
208/230-1-60 Schematic/Component Arrangement 50DK508514 7
208/230-3-60 Schematic/Component Arrangement 50DK508516 8
460-3-60 Schematic/Component Arrangement 50DK508519 9
575-3-60 Schematic/Component Arrangement 50DK508522 4
208/230-3-60* Schematic/Component Arrangement 50DK509083 10
460-3-60* Schematic/Component Arrangement 50DK509085 11
007
208/230-3-60 Schematic/Component Arrangement 50DK508517 12
460-3-60 Schematic/Component Arrangement 50DK508520 13
575-3-60 Schematic/Component Arrangement 50DK508523 14
008-014
208/230-3-60 Schematic/Component Arrangement 50DK508790 15
460-3-60 Schematic/Component Arrangement 50DK508791 16
575-3-60 Schematic/Component Arrangement 50DK508792 17
DESCRIPTION 48TF,TM UNIT SIZE FIG NO.
BASE UNIT SERIAL NUMBER FOR
FACTORY-INSTALLED OPTIONS
Apollo Controls Wiring Including Indoor Air Quality 004-014 18 From 2492Gxxxxx
Apollo Thermostat Wiring – Typical 004-007 19 From 0395Gxxxxx
008-014 20
Convenience Outlet Schematic 004-014 21 From 0798Gxxxxx
Durablade Economizer Wiring 004-014 22 From 3295Gxxxxx*
Differential Enthalpy Control (Durablade) 004-014 23 From 3295Gxxxxx*
Solid-State Enthalpy Control (Durablade) 004-014 24 From 3295Gxxxxx*
EconoMi$er Wiring 004-014 25 2099Gxxxxx — 0702Gxxxxx†**
EconoMi$er Dry Bulb Sensor Wiring 004-014 26 2099Gxxxxx — 0702Gxxxxx
EconoMi$er Enthalpy Sensor Wiring 004-014 27 2099Gxxxxx — 0702Gxxxxx
EconoMi$er Power Exhaust Wiring with the Switch in the Actuator 004-014 28 2099Gxxxxx — 4501Gxxxxx
EconoMi$er Power Exhaust Wiring with the Switch Outside the Actuator 004-014 29 4501Gxxxxx — 0702Gxxxxx
EconoMi$er2 Wiring 004-014 30 From 0802Gxxxxx**
Differential Enthalpy Wiring (EconoMi$er2) 004-014 31 From 0802Gxxxxx
Fire and Smoke Control Wiring (EconoMi$er2) 004-014 32 From 0802Gxxxxx
Indoor Air Quality Sensor Wiring (EconoMi$er2) 004-014 33 From 0802Gxxxxx
Power Exhaust, 208/230, 575 V Units (Economi$er2) 004-014 34 From 0802Gxxxxx
Power Exhaust for 460 V Units (Economi$er2) 004-014 35 From 0802Gxxxxx
Economi$er2 with PremierLink™ or 4-20 mA Control 004-014 36 From 0802Gxxxxx
Factory-Installed Non-fused Disconnect 004-014 37 From 0395Gxxxxx
Motormaster® I Control Wiring Details 004-014 38 Accessory Only
Motormaster II Control Wiring Schematic 004-007 39
008-014 40
Motormaster IV Control Wiring Schematic 004-007 41
008-014 42
Novar Controls Wiring (EMT3051) 004-014 43 From 2900Gxxxxx
Novar Controls Wiring (EMT2024) 004-014 44 From 2900Gxxxxx
PremierLink Controls Wiring 004-014 45 From 4601Gxxxxx**
PremierLink Controls Wiring with Dual Terminal Block 004-014 46 From 4002Gxxxxx**
PremierLink Controls Wiring with Dual Terminal Block and 62AQ Energy$Recycler 004-014 47 From 2102Gxxxxx**
Smoke Detector Shutdown — Single-Phase 004-014 48 From 0802Gxxxxx
Smoke Detector Shutdown — Three-Phase 004-014 49 From 0802Gxxxxx
Time Guard II Device 004-014 50 Accessory Only
Two-Position Damper Wiring 004-014 51
Field-Installed 62AQ Energy$Recycler Accessory Wiring (Typical) 004-014 52
48TF,TM004-014
3 to 12
1
/
2
Tons
Gas Heating/Electric Cooling Units