Carrier Ecologic 30GX080-265 - Page 100

100 pages

Save Page as PDF

To Previous Page

Manufacturer reserves the right to discontinue, or change at any time, speciﬁcations or designs without notice and without incurring obligations.

Book 2

Tab 5c

PC903 CatalogNo.533-062 PrintedinU.S.A. Form30G,H-3T PgCL-8 1099 1-98 Replaces:30G,H-2T

Main Page

Table of Contents1
Safety Considerations1
General2
Major System Components3
Processor Module (PSIO-1)3
DSIO-HV Relay Module3
Electronic Expansion Device Module3
Compressor Protection Module (CPM)3
PSIO-2 (8052) Module3
Keypad and Display Module (also Called HSIO-II)3
Control (LOR) Switch3
Operation Data3
Electronic Expansion Device (EXD)3
Oil Pumps4
Motor Cooling4
Back Pressure Valve (30GX and 30HXA Only)4
Sensors4
Compressor Protection Module (CPM)4
- Outputs4
- Inputs4
Wye-Delta Vs Across-The-Line (XL) Starting Option5
Capacity Control6
- Minutes off Time6
- Close Control7
- Lead/Lag Determination7
- Capacity Sequence Determination7
- Minimum Load Valve7
Head Pressure Control8
- Adjusting Pid Routines10
- Pump Control10
- Cooler Pump Control10
- Condenser Pump Control12
Cooler Heater Control13
Keypad and Display Module13
- (Also Called HSIO-II)13
- Accessing Functions and Subfunctions13
- Automatic Default Display13
- Status Function16
- Test Function25
- History Function25
- Set Point Function25
- Service Function30
- Schedule Function37
Temperature Reset39
- External Temperature Reset39
- Externally Powered Reset39
- Return Fluid Temperature Reset39
Demand Limit39
- Externally Powered Demand Limit42
Troubleshooting43
Checking Display Codes43
Unit Shutoff43
Complete Unit Stoppage43
Single Circuit Stoppage43
Restart Procedure43
- Power Failure External to the Unit43
Alarms and Alerts43
Compressor Alarm/Alert Circuit43
EXD Troubleshooting Procedure50
- Inspecting/Opening Electronic Expansion Valves51
- Inspecting/Opening Economizers51
Service52
Servicing Coolers and Condensers52
- Tube Plugging52
- Tightening Cooler/Condenser Head Bolts52
Inspecting/Cleaning Heat Exchangers53
Water Treatment53
Condenser Coils (30GX Only)53
- Coil Cleaning53
Condenser Fans (30GX Only)54
Refrigerant Charging/Adding Charge54
Oil Charging/Low Oil Recharging55
Oil Filter Maintenance56
- Replacing the External Oil Filter56
- Replacing the Internal Oil Filter56
Compressor Changeout Sequence56
- Burnout Clean-Up Procedure58
Moisture-Liquid Indicator58
Filter Drier58
Liquid Line Service Valve58
Thermistors58
- Thermistor Replacement58
Pressure Transducers59
- Pressure Transducer Calibration59
Safety Devices62
- Compressor Protection62
- Cooler Protection62
Relief Devices62
Control Modules64
- Processor Module (Psio-1), High Voltage64
- Relay Module (Dsio-Hv), and Exv Driver64
- Module (Dsio-Exv), 12/6 Module (Psio-2)64
- Red Led64
- Green Led64
Carrier Comfort Network (CCN) Interface64
- Processor Module (Psio-1)66
- High Voltage Relay Module (Dsio-Hv)66
Replacing Defective Processor Module66
Winter Shutdown Preparation66
Pre-Start-Up Procedure67
Start-Up and Operation67
Field Wiring68
- (Compressor Must Trip Amps)74
  - Appendix A74
  - APPENDIX B (Capacity Loading Sequence)77
APPENDIX C (Available Accessories)80
APPENDIX D (CPM Conﬁgurations)81
APPENDIX D (CPM Configurations)86
APPENDIX E (Cooler and Condenser Pressure Drop)86
APPENDIX F (Typical System Components)89
Index91

Carrier Ecologic 30GX080-265 - Page 100

Table of Contents

Related product manuals