Case W9 - Scheduled Maintenance

1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
MAINTENANCE/LUBRICATION
Scheduled Maintenance
Component
Service
Comments
Every 10 Hours Or Daily
Load e r Pivot Point s Including R ear
Axle Mounting Pivot Pins, Steering
Cylinder and Link age
Grease
Lithium "Soap-Base" Gr ease
Engine Oil
Check
Rear Wheel Trunnion Sockets
Gr ease
Lithium "Soap-Base" Gr ease
Oil Bath Air Cleaner
Ch eck and
Air cleaner must be serviced
service as
when dirt in oil cup is 1 /2
required
inch deep.
Every 60 Hours Or Weekly
Drive Shaft Universal Joints
NOTE: Slip joints, every 1000 hrs.
Grea se
Lithium "Soap-Base" Gr ease
Hydraulic Oil
Check
Differential Oil
Check
Planetary Oil
Check
Transmission Oil
Check
Power Ste e ring Oil
Check
Hydrovac Breath er
Cl ean
Foot Throttle Cross Sh af t
Lubricat e
Engine Oil, A F ew Drops
Every 120 Hours Of Operation
13. Engine Oil
Drain and
Re fill
G rease
With Filter, 13 quarts l
14. Distributor
Without Filter, 12 quarts
Lithium "Soap-Base" Greas e
Every 240 Hours Of Operation
15.
Steering G ear Bo x
Ch eck
16.
Engine Oil Filter Ch a ng e
Every 500 Hours Of Operation
17.
Hydrovac Filter
Cl ean
18.
Hydrovac Cylinder
Lubricat e
1 oz. C ase TCH Oil
Every · 1000 Hours Of Operation Or Yearly
19 . Differential Oil
Drain and Ref ill
Ref er to page 5.
20.
Planetary Oil Drain a nd Re fill
R efe r to page 5.
21.
Transmission Oil
Drain and Refill Case TCH Oil
22.
Tr a nsmission Oil Filter
Re place
23.
Transmission Oil Strainer
Cl ea n
24.
Tr a nsmission Breather
Clean
25.
Hydraulic Oil
Dr a in and Re fill
c:,se TCH Oil
26.
Hydraulic Oil Filter and Breather
Replac e
27.
Po\\·er St eeri ng Oil Filt er
Replace
28.
Hydrovac Filter
R ep l ace
3
Find manuals at https://best-manuals.com