CHART 3000 - User Manual

64 pages

Save Page as PDF

To Next Page

Part Number 20930593 Rev. C

Designed and Built by:

Chart Inc.

1300 Airport Dr.

Ball Ground, GA 30107 USA

(800) 400-4683

Product Manual

Perma-Cyl

MicroBulk Storage System

w/ FlexFill

™

Piping Option

1000/1500/2000/3000/5500

Main Page

Questions and Answers

K
Kyle HardinNov 6, 2025
Why is there no gas to gas-use equipment from my CHART 3000?
- T
  taylorashleyNov 6, 2025
  There might be several reasons for this problem: * The Perma-Cyl tank might be empty. In this case, switch to the emergency gas supply and call your gas supplier for a delivery. * The gas-use valve to the final line regulator or other downstream valves might be closed. Open the necessary valves and ensure there are no obstructions in the line or valve. * The pressure builder may not be building sufficient pressure. Open the pressure building regulator control valve and allow pressure to build, or adjust the setting on the regulator to a higher pressure. If the tank pressure still fails to rise, consult the section on low tank pressure. * The final line pressure regulator might be set too low or malfunctioning. Ensure the gas use valve is open and the tank pressure is at least 25 p...
S
summereatonNov 21, 2025
What to do if there is frost or ice on my CHART 3000 tank?
- T
  Tina ReedNov 21, 2025
  Frost or ice on the sides, bottom, top-center, or plumbing of your CHART Storage tank can occur due to several reasons: * It could be a normal condition during and following gas use, liquid use, or filling. In this case, no action is needed, but check the tank for frost/leaks before use. * If the tank is being used for continuous flow and not receiving enough ambient heat, move it to a warmer location, add additional environmental heat and/or warm airflow to the outer piping, components, and sides of the tank, or add a switchover system to allow the tank to rest and warm up when not in use. * A leak in the gas supply lines, gas-use equipment, or tank plumbing could be the reason. If frost is present even after an extended period with no gas or liquid use, evacuate and ventilate the ...