Coyote CCX3 - Page 12

10
Pre‐OperationLeakTesting
DANGER
1. Donotinsertanytoolintothevalveoutletorsafetyreliefvalve.Youmaydamagethevalveandcausea
leak.Leakingpropanemayresultinexplosion,fire,severepersonalinjury,ordeath.
2. Ifaleakisdetectedatanytimeoryoucannotstopagasleak,
immediatelyclosepipelinevalveandcallLP
gassupplieroryoufiredepartment!
3. Checkallgassupplyfittingsbeforeeachuseandeachtimethegassupplycylinderisconnectedtothe
regulator.Haveaqualifiedservicetechnicianleaktestthegrillanytimeapartofthegas
systemis
replaced.
WARNING
Neverattempttoattachthisgrilltotheself‐containedLPgassystem.Donotusegrilluntilleaktesting.
BeforeTesting
DO NOT smoke while leak testing. Extinguish all open flames. Never leak test with an open flame. Mix a
solutionofequalpartsmilddetergentorliquidsoapandwater.

LeakTestingValves,HoseandRegulator
1.TurnallgrillcontrolknobstoOFF.
2.BesurehoseistightlyconnectedtoLPtank.
3.CompletelyopenLPtankvalvebyturningcylindervalve
knobcounterclockwise(righttoleft).Ifyouheararushing
sound, turn gas off immediately. There is amajor leakat
the connection.
 Correct before proceeding by calling
franchiserforreplacementparts.
4.Brush soapy solution onto areas where bubbles are
showninLPtank(seepicture).
5.If“growing”bubblesappear,there isaleak.CloseLP
tankvalveimmediatelyandretightenconnections.Ifleads
cannotbestoppeddonottryto
repair.Callfranchiserfor
replacement.
6.AlwayscloseLPtankvalveafterperformingleaktestbyturningcylindervalveknobclockwise.

NOTE:Whenleaktestingthisappliance,makesuretotestandtightenalllooseconnections,includingtheside
burner.Aslightleakinthesystemcanresultinalowflame,orahazardouscondition.
LPGasSupplyCylinder Disconnection
1. Turntheburnervalvesoff.
2. Turnthetankvalveoff.(Turnclockwisetostop).
3. Detachtheregulatorassemblyfromthetankvalvebyturningthequickcouplingnutcounterclockwise.
