Daikin DPS010 - Modulating Gas Furnace Ignition Control; Ignition Control Module for Modulating Gas Furnace

122 pages

Save Page as PDF

To Next Page

To Previous Page

DPS 003–015 (only) Ignition Control Module for Modulating Gas Furnace

Figure 54: Typical Modulating Gas Furnace Electrical Schematic with Sensor

opTIonal gas heaT

www.DaikinApplied.com 53 IM 1125-7 • REBEL ROOFTOPS

Main Page

Default Chapter2
- Table of Contents2
Introduction3
- General Information3
- Unit Nameplate3
- Hazard Identification Information3
Mechanical Installation4
- Installer Responsibilities4
- Receiving Inspection4
- Service Clearance4
- Ventilation Clearance4
- Overhead Clearance6
- Roof Curb Assembly and Installation6
- Rigging and Handling10
- Unit Piping - Condensate Drain Connection12
- Damper Assemblies12
- Cabinet Weather Protection13
- Installing Ductwork13
Electrical Installation15
- Pre-Construction15
  - All Units16
  - Field Control Wiring17
Refrigeration System19
- Piping System19
- DPS 003-015 Component Description21
- DPS 016-028 Ton Component Description27
- VFD Compressor Operation - DPS 016-02829
- Variable Speed Scroll Compressor33
Optional Modulating Hot Gas Reheat36
- Modulating Hot Gas Reheat36
Optional Electric Heat39
- Electric Heater Design39
Optional Gas Heat40
- Daikin Tubular Heater Series40
- Gas Furnace Design40
- Gas Heating Capacity Data41
- DPS 003-015 Sequence of Operation48
- DPS 016-028 Sequence of Operation49
- Start-Up Procedures50
- Operating Procedures51
- Staged Gas Furnace52
- Modulating Gas Furnace53
- DPS 003-015 (Only) Gas Furnace Ignition and Control54
- Troubleshooting54
- VB-1200 Trouble Shooting Guide54
- DPS 016-028 Gas Furnace Ignition Troubleshooting60
Optional Hot Water Heat65
- Hot Water Heater Design65
Optional Energy Recovery Wheel66
- System Description66
Optional Outdoor Air Monitor69
- Thermal Dispersion Airflow Measurement Technology69
ECM Motor74
Unit Options76
- Economizer Enthalpy Control76
- External Time Clock76
- Exhaust Fan Option76
- Proof-Of-Airflow and Dirty Filter Switch76
- Duct High Pressure Limit76
- Convenience Receptacle (Field Powered)77
- Convenience Receptacle (Unit Powered)77
Wiring Diagrams78
Sequence of Operation90
- Operating States90
- Mechanical Cooling91
- Economizer91
Preparing the Unit for Start up92
- Pre-Start of Unit92
- Spring Isolated Fans92
- Servicing Control Panel Components93
- Power-Up93
- Fan Start-Up93
Check, Test and Start Procedures94
- Economizer Start-Up94
- Compressor Start-Up94
- Set up for Optimum Control95
- Air Balancing95
- Energy Recovery Wheel96
Final Control Settings97
- Maintaining Control Parameter Records97
Maintenance98
- Performing Service Maintenance98
- Planned Maintenance98
- Unit Storage98
- Periodic Service and Maintenance99
- Refrigerant Charge100
- Servicing Refrigerant Sensors or Switches101
- Servicing Optional Electric Heater101
- Servicing the Compressor Ground Fault Interrupter101
- Phase Voltage Monitor (PVM)101
- Cleaning Option E Coated Coils102
Service and Warranty Procedures103
- Replacement Parts103
- Scroll Compressor103
- In-Warranty Return Material Procedure103
Warranty Registration Form104
Quality Assurance Survey Report108
Appendix - Keypad/Display Menu Structure110

Daikin DPS010 - Modulating Gas Furnace Ignition Control; Ignition Control Module for Modulating Gas Furnace

Table of Contents

Related product manuals