Datsun 1200 1971 User Manual

Datsun 1200 1971

136 pages

To Next Page

To Next Page

Page #1 background image

Loading...

Page #1 background image

DXD

N

@J

@o

@

o

Jl

feU

f

I

I

j

lIDrnlli

rnrnJW

CRAKE

PU3

IS1

RS

i

C

Table of Contents

Quick Reference Index2
Table of Contents4
Maintenance & Tune-Up7
Valve Clearances8
Adjusting Drive Belt Tension8
Engine Oil8
- Checking Engine Oil Level9
- Compression Pressure Test9
Oil Filter9
Coolant9
- Battery10
- Checking the Specific Gravity of Battery-Electrolyte10
- Ignition Timing10
- Test Conclusion10
- Carburetor11
- Checking Ignition Timing11
- Condenser11
- Idle Limiter Cap12
- Fuel Filter13
  - Fuel Strainer13
  - Engine14
Sectional View of a 12 Engine14
Description14
Removal14
- Cleaning and Inspection15
- Oil Pump Removal15
Installation15
Disassembl y15
- Cylinder Head Bolts Removal Sequence16
- Oil Strainer Removal16
- Rocker Shaft Assembly Removal16
- Water Pump Removal16
- Baffle Plate and Net Removal17
- Camshaft Plate Removal17
- Piston and Connecting Rod Assembly Removal17
- Timing Chain Cover Removal17
- Checking Cylinder Head Mating Face18
- Cylinder Head Surface Flatness18
- Inspection and Repair18
- Preparation18
- Valve Assembly18
- Crankshaft24
- Flywheel25
- Precaution25
Assembly25
Assembly32
- Adjusting Regulator33
- Regulator Valve33
- Electrical System34
- Exploded View of Starting Motor35
- Exploded View of Alternator35
- Trouble Shooting36
Removal36
Installation36
- View of Removing Cover38
- Structural View38
Regulator38
Trouble39
- Ignition System41
- Ignition System Circuit Diagram42
- Distributor42
- Checking and Adjustment42
- Structure D411-8043
- Exploded View of Distributor D411-8043
- Remove Spark Plugs44
- Replace if Deviated44
- Measuring Breaker Point Spring Tension44
- Adjusting Point Gap44
- Carbon Fouled45
- Oil Fouled45
- Overheating45
- Cleaning and Regap45
Spark Plugs45
- Fuel System46
- Fuel Filter Description47
Removal47
Installation47
Fuel Pump47
- Pull Rod Removal48
- Static Pressure Test48
- Structure of Fuel Pump48
- Testing48
- Capacity Test49
Description49
Inspection49
Assembly49
Carburetor49
- Idling Adjustment50
- External View of Carburetor50
- Adjusting Float Level51
- Fuel Level Adjustment51
- Fast Idle Adjustment51
- Adjusting Vacuum Break52
- Adjusting Fast Idle52
- Adjusting Choke Unloader53
- Vacuum Break Adjustment53
- Choke Unloader Adjustment53
- Bi-Metal Setting54
- Adjusting Dash Pot54
- Adjusting Interlock (Primary and Secondary Throttle Valves)54
- Remove the Air Cleaner55
- Removing Choke Chamber and Servo Diaphragm55
- Dash Pot Adjustment (Automatic Transmission Car Only)55
- Adjustment of Interlock Opening of Primary and Secondary Throttle Valves55
Removal55
Disassembly55
- Disassembling Accelerator Pump and Bi-Meral Cover56
- Removing Throttle Chamber56
- Removing Throttle Valve56
- Assembly and Installation57
- Jets57
Fuel System57
- Cooling System60
- Water Pump60
- Water Pump and Front Cover60
- Installation61
  - Thermostat Inspection61
  - Thermostat Removal61
  - Radiator Removal62
  - Front Disc Brake Components63
  - Piston Seal Automatic Adjusting Operation63
  - Removing Retaining Pin63
  - Brake Pad64
  - Reinstallation64
  - Replacement64
  - Arrow Mark on Shim65
  - Piston Pushing in Position65
  - Removing Caliper Assembly Installation Bolt65
  - Removing Strut Assembly and Knuckle Arm Installation Bolt65
  - Calipers66
  - Cylinder Body and Piston66
  - Piston66
  - Seals66
  - Installing Boot67
  - Measuring Deflection of Disc67
  - Reassembly67
  - Rotor67
  - Correcting Bias Spring Position68
  - Installation of Yoke Spring68
  - Measuring Starting Torque68
  - Rear Brake Construction69
  - Removing Hand Brake Wire69
  - Hand Brake70
  - Rear Drum Brake70
- Removal70
  - Removing Brake Disc70
  - Return Spring Dimensions70
  - Hand Brake Construction71
  - Measuring Sliding Resistance71
  - Disconnecting Rear Cable from Rear Axle Housing72
  - Hanger Strap Mounted on Rear Axle Housing72
  - Removing Hand Brake Lever72
  - Removing Turn-Buckle72
  - Adjustment73
  - Brake Pedal Height73
  - Front Disc Brake73
  - Rear Brake73
  - Adjusting Turn-Buckle74
- Adjustment74
  - Bleeding Hydraulic System74
  - Connecting Vinyl Hose to Air Bleeder (Rear)74
  - Front Suspension77
  - Front Axle and Suspension Assembly78
  - Recommendations78
  - Cross-Sectional View of Front Axle (Drum Type Brake)79
- Lubncatlon81
  - Steering83
  - Steering Gear Components84
  - Rear Drive & Suspension86
  - Differential87
  - Sectional View of Rear Axle87
  - Rear Suspension88
  - Sectional View of Differential Carrier88
  - Rear Shock Absorber89
  - Removing Shock Absorber Upper Bracket89
  - Removing the Shock Absorber Lower End89
  - Clutch Pedal91
  - Construction of Clutch91
  - Clutch Master Cylinder92
  - Pedal Height Adjustment92
  - Bleeding Clutch System93
  - Transmission94
  - F4W56 Gear Tram95
  - F4W56 Transmission95
  - Four Speed Transmission95
  - R3W56 Gear Tram95
  - R3W56 Transmission96
  - Three Speed Transmission96
  - Automatic Transmission Description98
  - Automatic Transmission99
  - Fluid Recommendation99
  - Identification Number Stamped Position99
  - Automatic Transmission Identification100
  - Model Code100
  - Unit Number100
  - Body Work101
  - Centering the Hood Lock102
  - Hood Lock Mechanism102
  - Removing Hood102
  - Removing Hood Hinge102
  - Adjusting Hood Lock Control Level Operating Force103
  - Checking Free Play of Hood Panel103
  - Removing Hood Lock Control Lever103
  - Section View of Hood Lock103
  - Adjusting Dove-Tail Bolt104
  - Adjusting Hood Tightness104
  - Lubricating Points104
  - Safety Catch Lever Position104
  - Installing Torsion Bar105
  - Trunk Lid and Hinge Construction (Sedan)105
- Adjustment106
- Back Door and Hinge Constructions106
- Removal106
- Trunk Lid Lock106
- Trunk Lid Torsion Bar106
  - Front Door Construction107
  - Rear Door Construction107
  - Wiring Diagram (Manual Transmission)108
  - Wiring Diagram (Automatic Transmission)109
- Bulb Specifications110
  - Head Lamp111
  - Thermometer and Fuel Meter112
  - Oil Pressure and Ignition Warning Lamp116
  - Recommended Lubricant Specifications119
  - Service Data and Specifications120
  - Service Data121
- Engine123
- General Specification123
- Fuel System129
- Specifications and Service Data129
- Tlghtemng129
- Torque129
- Starter131
- Alternator132
- Approximate Refill Capacity132
- Regulator133
- Ignition Coil134
- Clutch135
- Other Drake Automotive Books136

Questions and Answers:

Need help?

Do you have a question about the Datsun 1200 1971 and is the answer not in the manual?

Datsun 1200 1971 Specifications

General

Brand	Datsun
Model	1200 1971
Category	Automobile
Language	English

Related product manuals

Datsun 1200 1973

Preview: Datsun 180B

Preview: Datsun 210 1979

Datsun 210 1979

Datsun 710 1975

Preview: Datsun 280ZX 1980

Datsun 280ZX 1980

Datsun 1981 Pick-Up

Preview: Datsun 1968-1973 510

Datsun 1968-1973 510

Preview: Datsun 620 Series 1977

Datsun 620 Series 1977

Preview: Datsun 510 series

Datsun 510 series