Delfield Specification Line GAR2P-S - User Manual

104 pages

Save Page as PDF

To Next Page

To Next Page

Loading...

Specification Line®

GA Series

Original Instructions

Service Manual

This manual is updated as new information and models are released. Visit our website for the latest manual.

Part Number GA_SM 08/18

Table of Contents

Default Chapter3
- Table of Contents3
Section 15
General Information5
- Model Numbers5
- Serial Number Information5
- Warranty Information5
- Regulatory Certifications5
Section 27
Installation7
- Location7
- Clearance Requirements7
- Drain Connections7
  - Floor Drain Required7
- Weight, Capacity & Dimensions of Equipment8
- Electrical Service9
- Leg & Caster Installation11
- Level & Stable12
- Shelf Installation12
- Reversible Door Instructions12
  - Applicable to Full Door Models12
- Roll-In & Roll-Thru Installation13
- New Hinge Cartridge Installation14
- Accessory Interior Drawer Installation14
- T-1 Tray Slide Installation15
- Tray Slide Installation16
- T-3 Tray Slide Installation17
- T-4 Rack Slide Installation18
- Optional Foot Pedal Installation Instructions19
Section 321
Operation21
- Refrigerator & Freezer Operation21
- Refrigerator & Freezer Start up21
  - Evaporator Fan Operation22
- Heated Cabinet Operation22
- Heated Cabinet Start up22
  - Fan Operation22
  - High Temperature Safety Device23
- Power down23
- Home Screen23
- Touchscreen Password24
- Configuration Screen25
- Settings Screen25
- Units26
- Defrost Type (Refrigerator & Freezer)26
- Set Box Temperature27
- Alarm Management28
- Network Connection28
- Interior Light29
- Time / Date30
- Language30
- LCD Brightness31
- Manual Defrost31
- Web Application31
  - Kitchenconnect31
- Mobile Application31
  - Specification Line Connect31
- Application Operation32
  - Equipment Management32
Section 433
Maintenance33
- Responsibility33
- Interior Cleaning34
  - Gaskets34
  - Preventing Blower Coil Corrosion34
- Exterior Cleaning34
  - Drain34
  - Doors/Hinges34
- Cleaning the Condenser Coil34
Section 535
Troubleshooting35
- Problem -> Cause -> Correction Chart35
Section 637
Control37
- Service Screens37
Section 749
Component Check Procedures49
- Evaporator Fan Access49
- Condenser Fan Access50
- Unit Air Flow Design50
- Frame Heater Routing51
- Door Hinges52
- Temperature Probe Resistance53
- LED Light Replacement54
- Door Gasket55
Refrigeration57
Section 857
R29057
- Charging Procedures57
- System Contamination Clean-Up58
- Mild System Contamination Clean-Up Procedure59
- Severe Contamination Clean-Up Procedure59
- Filter Driers60
- Refrigerant Re-Use Policy60
- Properties of R-290 (Propane)61
- Service Procedures62
- Review63
- Normal Operating Temperatures64
Diagrams95
Section 995
- Refrigerator Wiring Diagram95
- Freezers with One Compressor Wiring Diagram96
- Freezers with Two Compressors Wiring Diagram97
- One Section Dual Temperature Wiring Diagram98
- Two Section Dual Temperature Wiring Diagram99
- One Section Heated Cabinet Wiring Diagram100
- Two Section Heated Cabinet Wiring Diagram101

Questions and Answers

D
Douglas RobertsAug 9, 2025
Why is my Delfield Specification Line GAR2P-S Refrigerator running constantly?
- B
  boyddeannaAug 10, 2025
  If your Delfield Refrigerator's condensing unit runs for long periods, several factors could be the reason. An excessive amount of warm product placed in the cabinet may require additional cooling time. Prolonged door openings or doors left ajar can also cause this issue, so ensure doors are closed when not in use and avoid keeping them open for extended periods. Check the door gaskets to confirm they are sealing properly; adjust the door or replace the gasket if needed. A dirty condenser coil can also contribute to this problem, so clean the coil. Finally, an iced-over evaporator coil could be the culprit; turn the unit off and allow the coil to defrost, and make sure the thermostat is not set too cold, also check the gasket condition.
E
Eric RiggsAug 16, 2025
Why is the temperature in my Delfield Specification Line GAR2P-S Refrigerator too high?
- T
  Tracy FloresAug 16, 2025
  If the cabinet temperature of your Delfield Refrigerator is too high, it could be due to several reasons. First, check if the thermostat is set too high and adjust it to a lower temperature. Ensure proper air circulation within the cabinet by re-arranging the product. An excessive amount of warm product placed inside may also cause this issue, so allow adequate time for the product to cool down. Avoid prolonged door openings or doors left ajar. A dirty condenser coil can also contribute to the problem, so clean it. Lastly, an iced-over evaporator coil could be the cause; turn off the unit and allow the coil to defrost, ensuring the thermostat isn't set too cold and checking the gasket condition.
L
Linda MyersAug 25, 2025
What to do if my Delfield Specification Line GAR2P-S is not running?
- P
  patelkellyAug 25, 2025
  If your Delfield Refrigerator cabinet is not running, there are several potential causes. A blown fuse or tripped circuit breaker could be the issue; replace the fuse or reset the circuit breaker. Ensure the power cord is plugged in. Check that the thermostat isn't set too high and lower the temperature setting if needed. Verify that the system is turned on. Also, the refrigerator might be in defrost cycle, in that case wait for it to finish.
M
michael52Aug 31, 2025
Why is my Delfield Specification Line GAR2P-S Refrigerator freezing food?
- R
  rachelloweAug 31, 2025
  If your Delfield Refrigerator is freezing product, the thermostat might be set too low; adjust it to a higher temperature. A dirty condenser coil can also cause this issue, so clean the coil. Also, ensure there is enough cabinet clearance for proper refrigeration system operation; adjust the cabinet's position to gain adequate clearance.

Summary

Installation Procedures

Site Selection and Clearances

Guidelines for choosing a suitable location and required installation clearances.

Electrical Connections and Grounding

Requirements for electrical hookup, grounding, and GFCI protection.

Unit Operation

Start-up and Basic Controls

Temperature, Defrost, and Alarm Management

Adjusting temperature, defrost settings, and managing alarms.

Troubleshooting Guide

Problem, Cause, and Correction Chart

A comprehensive guide to diagnosing and resolving common unit issues.

Control System Functions

Service Screens and Diagnostics

Accessing service screens, viewing diagnostics, and relay statuses.

Alarm History and Management

Refrigeration System

R290 Refrigerant Handling and Safety

Guidelines for R290 refrigerant connections, charging, safety, and service.

Normal Operating Temperatures

Diagrams

Wiring Schematics

Delfield Specification Line GAR2P-S Specifications

General

Type	Reach-In Refrigerator
Model	GAR2P-S
Brand	Delfield
Series	Specification Line
Exterior Material	Stainless Steel
Number of Doors	2
Phase	1
Shelves	6
Refrigerant	R290
Voltage	115V
Hertz	60 Hz
Certifications	NSF

Related product manuals

Specification Line GAR1P-S

Specification Line GARPT1P-S

Specification Line GARRI2P-S

Specification Line GARRI1P-S

Specification Line GAH2-S

Specification Line GAF1P-S

Specification Line GAHPT2-S

Preview: Specification Line GADTR1P-SH

Specification Line GADTR1P-SH

Delfield 6025-S

Preview: Delfield 6125XL-S

Delfield 6125XL-S

Delfield CoolScapes GBR2P-S

Delfield CoolScapes GBSF2P-S