Demco 1050 - DURING OPERATION

Page 8
• Install the safety chain by crossing the chains under the tongue and secure to the draw bar cage, hitch, or bumper
frame.
• Beware of bystanders, PARTICULARLY CHILDREN! Always look around to make sure that it is safe to start the
engine of the towing vehicle or move the unit. This is particularly important with higher noise levels and quiet cabs,
as you may not hear people shouting.
• NO PASSENGERS ALLOWED- Do not carry passengers anywhere on or in the tractor or equipment.
• Keep hands and clothing clear of moving parts.
• Do not clean, lubricate, or adjust your equipment while it is moving.
• When halting operation, even periodically, set the tractor or towing vehicle brakes, disengage the PTO, shut off the
engine, and remove the ignition key.
• Be especially observant of the operating area and terrain- watch for holes, rocks, or other hidden hazards. Always
inspect the area prior to operation.
- DO NOT operate near the edge of drop-offs or banks.
- DO NOT operate on steep slopes as overturn may result.
- Operate up and down (not across) intermediate slopes. Avoid sudden starts and stops.
• Pick the levelest possible route when transporting across fields. Avoid the edges of ditches, gullies, and steep
hillsides.
• Be extra careful when working on inclines.
• Periodically clear the equipment of brush, twigs, or other materials to prevent buildup of dry combustible materials.
• Maneuver the tractor or towing vehicle at safe speeds.
• Avoid overhead wires or other obstacles. Contact with overhead lines could cause serious injury or death.
• Avoid loose fill, rocks, and holes; they can be dangerous for equipment operation or movement.
• Allow for unit length when making turns.
• Do not walk or work under raised components or attachments unless securely positioned and blocked.
• Keep all bystanders, pets, and livestock clear of the work area.
• Operate the towing vehicle from the operators seat only.
• Never stand alongside of unit with engine running or attempt to start engine and/or operate machine while standing
alongside of unit.
• Never leave running equipment attachments unattended.
• As a precaution, always recheck the hardware on equipment following every 100 hours of operation. Correct all
problems. Follow the maintenance safety procedures.
• SAFETY CHAIN -If equipment is going to be transported on a public highway, a safety chain should be obtained
and installed. Always follow state and local regulations regarding safety chain and auxiliary lighting when
towing farm equipment on a public highway. Be sure to check with local law enforcement agencies for your own
particular regulations. Only a safety chain (not an elastic or nylon/plastic tow strap) should be used to retain the
connection between the towing and towed machines in the event of separation of the primary attaching system.
DURING OPERATION
!