WARNING: RISK OF BURSTING
Air Tank: On February 26, 2002. the U.S. Consumer Product
Safety Commission published Release # 02-108 concerning air
compressor tank safety:
Air compressor receiver tanks do not have an infinite life. Tank life
isdependent upon several factors, some of which include operating
conditions, ambient conditions, proper installations, field modifica-
tions, and the level of maintenance. The exact effect of these fac-
tors on air receiver life is difficult to oredict.
If proper maintenance procedures are not followed, internal corro-
sion to the inner wall of the air receiver tank can cause the air tank
to unexpectedly rupture allowing pressurized a r to suddenly and
forcefully escape, posing risk of injury to consumers.
Yourcompressor air tank must be removed from service by the end
of the year shown on your tank warning label.
The following conditions could lead to a weakening of the air tank.
and result in a violent air tank explosion:
WHAT CAN HAPPEN
Failure to properly drain
condensed water from
air tank, causing rust and
thinning of the steel air tank.
HOWTO PREVENT IT
Drain air tank daily or after
each use. If air tank develops
a leak, replace it immediately
with a new air tank or replace
the entire compressor.
Modifications or atter_ pted ,
repa_rs to the air tank.
Never drill into. weld. or make
any modifications to the air
tank or its attachments. Never
attempt to repair a damaged or
leaking air tank. Replace with a
new air tank.
Unauthorized modifications to
the safety valve or any other
components which control air
tank pressure.
Attachments & accessories:
The air tank is designed
to withstand specific
operating pressures. Never
make adjustments or parts
substitutions to alter the factory
set operating pressures.
Exceeding the pressure * Follow the equipment
rating of air tools, spray guns. manufacturers
air operated accessories, recommendation and never
tires, and other inflatables exceed the maximum allowable
can cause them to explode or pressure rating of attachments.
fly apart and could result in Never use compressor to
serious injury, inflate small low pressure
objects such as children's toys.
footballs, basketballs, etc.
To Next Page
Loading...
Need help?
General
