Ducar DUELT24-4 - Maintenance and Deposits; Machine Safety

20
INSTRUCTION MANUAL
GB
C 15 Disengage the blade during transport and
HYHU\WLPHLWLVQRWXVHG
C 16 6WRS WKH HQJLQH DQG UHPRYH WKH NH\ DQG
disengage the blade:
- before leaving the machine;
- EHIRUH¿OOLQJXSZLWKSHWURO
- before removing the grass bag;
- before adjusting cutting height if the operation
is not performed from the driving seat.
&  Make sure the accelerator is at minimum
before switching off the engine.
&6WRSWKHHQJLQHUHPRYHWKHNH\DQGGLVFRQ-
nect the spark plug wire;
- LI \RX NQRFN DJDLQVW D IRUHLJQ ERG\ VWRS
the engine, disconnect the spark plug wire
DQGFDUHIXOO\ LQVSHFWWKHtractorIRU
DQ\ damage.
 +DYHDQ\GDPDJHVUHSDLUHGEHIRUH\RXVWDUW
the engine again; use the services of an
authorised after-sales centre.
- VKRXOG WKH PDFKLQH GLVSOD\ XQXVXDO YLEUD-
WLRQVVWRSWKHHQJLQHDQG LPPHGLDWHO\VHHN
the cause of the vibrations. As a rule, unusual
vibrations are an indication of a problem.
0$,17(1$1&($1''(326,76
D
1 Make sure all the nuts and screws are tight, so
the lawn tractor is in good operating condition
and safe to use.
D 2:DLWIRUWKHHQJLQHWRFRPSOHWHO\FRROGRZQEH-
fore before cleaning, adjusting or repairing.
'$1*(5RIEXUQV
' Never store the lawn tractor in a secluded area
ZLWKSHWUROLQWKHWDQNDVWKHIXPHVPD\UHDFK
DQDNHGÀDPHRUDVRXUFHRIVSDUNV
' Wait for the engine to cool down, before storing
the lawn tractor in a secluded area.
D
5,Q RUGHU WR UHGXFH WKH ULVN RI ¿UH NHHS WKH
HQJLQH WKH VLOHQFHU EDWWHU\ KRXVLQJ DQG
petrol deposit area free of grass, leaves or
H[FHVVLYHJUHDVH
D 6 )UHTXHQWO\ PDNH VXUH WKH JUDVV EDJ LV QRW
worn or torn.
')RUVDIHW\UHDVRQVUHSDLUDQ\ZRUQRUGDPD-
JHGSDUWV2QO\XVHRULJLQDOVSDUHSDUWV1RQ
RULJLQDOVSDUHSDUWVPD\QRWVXLWHSURSHUO\DQG
cause damages and dangers.
'6KRXOG\RXQHHGWRHPSW\WKHWDQNGRVRLQ
the open.
D 9:KHQWKHPDFKLQHKDVWREHSXWDZD\RUOHIW
unguarded, lower the blade deck and remove
WKHLJQLWLRQ NH\ WRSUHYHQWXQDXWKRULVHG SHU-
sons starting the machine.
'5HJXODUO\FKHFNRUKDYHDQDIWHUVDOHFHQWUH
check, the tightening of the blade and of the
engine supporting bolts.
D 11 Blade sharpening and balancing adjustment,
LQFOXGLQJUHPRYDODQGUH¿WWLQJDUHGHPDQGLQJ
RSHUDWLRQVZKLFKUHTXLUHVSHFL¿FFRPSHWHQFH
DV ZHOO DV VSHFLDO HTXLSPHQW HVSHFLDOO\ IRU
VDIHW\ UHDVRQV WKHVH RSHUDWLRQV PXVW EH
FDUULHGRXWE\DVSHFLDOLVHGDIWHUVDOHFHQWUH
The same applies to blade replacement with
a new one.
D
12 The lawn tractor blade is sharp and can cut
WKH VNLQ  <RX QHHG WR WDNH WKH QHFHVVDU\
SUHFDXWLRQV ZKHQHYHU \RX ZRUN QHDU RU RQ
the blade.
:HDUKHDY\JORYHV
0$&+,1(6$)(7<
Your lawn tractor has been designed in
accordanFH ZLWK VSHFL¿F VDIHW\ VWDQGDUGV 
7KDW LV ZK\ VDIHW\ V\VWHPV KDYH EHHQ ¿WWHG
VZLWFKHV W\SH
¿JSDUWZKLFKRSHUDWHDVIROORZV
A) prevent engine start unless all machine
safety conditions are in place.
&RQGLWLRQVWREHFRPSOLHGZLWK
1) start switch in position
2) parking brake engaged
 cutting blade disengaged
B) in case of lack of even one safety condition,
stop engine;
7KHHQJLQHVWRSVLI
1) the operator leaves the driving seat with blade
rotation enabled.
2) the grass bag is lifted without having disenga-
ged blade rotation
blade rotation is engaged without the bag ha-
YLQJEHHQ¿WWHG
 reverse gear is engaged without having disen-
gaged blade rotation.
+$=$5'1HYHUWDPSHUZLWKWKHVDIHW\
VZLWFKHV DQG WKHLU SRZHU OHDGV  ,Q
FDVHRIDIDXOWGRQRWXVH WKH PDFKL-
QH EXW FRQWDFW D TXDOL¿HG DIWHUVDOHV
FHQWUH