19
User Maintenance
It is important for safety that you carry out the following checks before use.
1. Visually check the machine for damage.
2. Visually check the tyres for damage.
3. Check the steering moves freely.
4. Check that the tiller is secure and that the tiller thumb-wheel is tight.
5. Check that the front and rear chassis halves are properly attached to each other.
6. Check that the seat is located correctly.
7. Check the armrests are secure.
8. The battery should be fully charged.
9. Keep your vehicle clean by using a damp cloth and soapy water – never use a hose.
Important – Possible faults
As you get used to your vehicle you will get a feel for how it behaves. If something feels unusual, for instance
the vehicle does not accelerate or brake smoothly; the brakes are not holding on a slope or the steering
feels different, stop using the scooter, contact your dealer immediately and explain to the engineer exactly
what the problem is.
Disposal
Contact your dealer for advice before you consider disposing of your scooter. They will be aware of the
environmental regulations in force at the time and will assist you to meet the applicable environmental legislation.
Servicing and Maintenance
1. This vehicle is designed for minimum maintenance. However it is recommended that your vehicle is
serviced at least once a year, by an approved Electric Mobility Dealer. If the vehicle is used constantly we
recommend a twice yearly maintenance.
2. Ensure the engineer stamps the Service Log (page 28) on completion of all servicing. Keep all receipts
for servicing and repairs with this handbook. This may add value when selling the vehicle.
3. When the vehicle is due for its annual service make sure you report any concerns you have,
preferably when you book the service (See points to look out for below).
4. On completion of the service, always test the vehicle before the engineer leaves and make sure you
are satisfied with the work carried out.
Points to look out for:
• Are there any strange noises from the wheels or does the frame creak when going over rough ground?
• Is the battery charged up correctly – is the “full” charge green light on after charging?
• Is the steering tight or is it loose when turning? Is there any play in the steering?
• Are the brakes effective ?
• Is there any damage to spigots or parts related to disassembly ?
• Has anything come loose?
• Does the vehicle perform as well as it did when it was new?
• Are there noises or rattles that were not there before?
• Are there any signs of damage, corrosion or cracking?
To Next Page
Loading...
