24
www.ferrisindustries.com
MAINTENANCE SCHEDULE
The following schedule should be followed for normal care of your rider and mower. You will need to keep a
record of your operating time. Determining operating time is easily accomplished by observing the elapsed time
recorded by the hour meter.
Regular Maintenance
Regular Maintenance
INSPECT MUFFLER AND SPARK
ARRESTER
Inspect the muffler for cracks corrosion, or other
damage. Remove the spark arrester, if equipped,
and inspect for damage or carbon blockage. If
replacement parts are required, make sure to use
only original equipment replacement parts.
WARNING
Replacement parts must be the same and
installed in the same position as the original
parts or fire could result.
RIDER MAINTENANCE
Before Each Use
Check Safety Interlock System
Check Rider Brakes
Check Rider / Mower for loose hardware
Every 100 Hours or Annually*
Clean Deck & Check / Replace Mower Blades
Lubricate Rider & Mower**
Clean Battery & Cables
Check Tire Pressure
Check Hydraulic Oil**
Every 250 Hours or Annually*
Change Hydraulic Oil Filter**
* Whichever comes first.
** More often in hot (over 85° F: 30°C) weather or
dusty operating conditions
ENGINE MAINTENANCE
Before Each Use
Check Engine Oil Level
Check Engine Coolant Level
Every 25 Hours
Check / Clean Cooling Fins & Intake**
Check Fuel Filter
Every 50 Hours
Check / Clean Spark Arrester***
Refer to Engine Manufacturer’s Owner’s Manual
Service Air Filter
Change Oil & Filter*
Check / Replace Spark Plugs
Annually
Change Engine Coolant
* Change original engine oil after first 5 hours of
operation.
** More often in hot (over 85° F: 30°C) weather or
dusty operating conditions
*** If equipped. Replace if damaged.
To Next Page
Loading...
