Ford 4630 - Page 16

126 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

xvi

Table of Contents

Quick Search1
Printing2
Table of Contents5
About this Manual6
Introduction7
Rops9
Safety Decals10
- The Tractor12
- Servicing the Tractor12
Safety Precautions12
- Operating the Tractor13
- Driving the Tractor13
- Operating the P.T.O.14
- Roll over Protective Structure14
- Diesel Fuel14
- Pre-Delivery Inspection15
Pre-Delivery Inspection17
Universal Symbols18
Controls, Instruments and Operation19
Controls, Instruments and Operation20
Operator's Seat20
- Seat Belt and Rops21
- Instrument Panel21
- Proofmeter21
- Engine Coolant Temperature Gauge22
- Engine Oil Pressure Warning Light22
- Instrument Console22
- Hand Throttle22
- Starting the Tractor23
- Key-Start Switch23
- Dual Power Switch23
- Engine Stop Control23
- Coolant Immersion Heater24
- Starting in Cold Weather24
- Starting the Tractor with Jump Leads25
- Parking Brake25
- Stopping the Engine25
- Differential Lock26
- Foot Controls26
- Foot Throttle26
- Footbrakes26
- Transmission and Dual Power27
- Clutch27
- 8 X 2 Constant Mesh Transmission27
- Dual Power Transmission28
Four Wheel Drive29
- Break-In Procedure30
- Attaching P.T.O. Driven Equipment31
- Slow Moving Vehicle Emblem31
Power Take-Off31
- Operating Independent P.T.O.32
- Belt Pulley33
- To Operate the Belt Pulley34
Three-Point Linkage34
- Lift Rods35
- Top Link35
- Telescopic Stabilizers36
- Linkage Categories36
- Hydraulic Lift Rocker36
- External Check Chains37
- Flexible Link Ends38
Hydraulic System38
- Upper Link Draft Control Operation39
- Position Control Operation40
- Operating Remote Cylinders with the A.S.C. Valve41
- Draft Control Operation with Position Control41
Remote Control Valves42
- Standard Remote Control Valves43
- Deluxe Remote Control Valves45
- Operating Double-Active Cylinders47
- Operating Single-Acting Cylinders47
- Operating Continuous Flow Hydraulic Equipment47
- Attaching and Detaching Trailed Equipment48
- Bleeding Remote Cylinders48
- Swinging Drawbar48
- Front Wheel Track Adjustment50
- Safety Chain50
Track Adjustment51
- Rear Wheel Track Adjustment55
- Power Adjusted Rear Wheels56
- Power Adjust Procedure58
- Changing Track Width Range58
Tractor Weighting60
- Cast Iron Weights61
- Weighting Limitations61
- Liquid Ballast62
Tire Inflation64
Lubrication and Maintenance65
Lubrication and Maintenance Chart66
- Access Panels68
- Hood Side Panel68
- Radiator Cowling and Grille68
- Radiator Grille68
- Engine Coolant Recovery System69
- Engine Oil Level69
- Radiator and Oil Cooler70
- Power Steering70
- Pre-Cleaner70
- Oil Bath Air Cleaner70
- Servicing the Dry Air Cleaner71
- Dry Air Cleaner71
- Fuel Filter/Sediment Separator73
- Clutch Pedal Free Play Adjustment73
- Tires73
- Front and Rear Wheel Nuts73
- Rear Axle Oil Level74
- Belt Pulley Oil Level74
- Front Axle Differential Oil Level74
- Front Axle Hub Oil Levels75
- Grease Fittings and Pivots75
- Engine Oil and Filter77
- Transmission Oil Level78
- Footbrake Adjustment79
- Hydraulic Oil Filter79
- Handbrake Adjustment80
- ROPS Bolts81
- Fan Belt81
- Front Wheel Bearings83
- Starter Motor Pinion83
- Valve Tappet Clearance84
- Bleeding the Fuel System86
- Rear Axle Oil87
- Transmission Oil87
- Front Axle89
- Front Axle Hub Oil89
- Belt Pulley Oil90
- Power Steering Oil and Filter90
- Coolant Inhibitor/Filtration System91
- Tractor with Coolant Filter92
- External Headlights94
- Headlight Bulb Replacement94
- Engine Coolant94
General Maintenance94
- Grille-Mounted Headlights95
- Rocker Switch Bulb Replacement96
- Battery96
- Fuses96
- Alternator97
- Preparing the Tractor for Use after Storage98
- Tractor Storage98
- Engine Idle Speed98
- Specifications99
- General Dimensions100
- Lubricants108
- Front Tire Pressures and Permissible Loads109
- Rear Tire Pressures and Permissible Loads113
- Road Speeds113
- Road Speed Decal120
- Reduction Gear Set120
Index121

Related product manuals

Preview: Ford 9N

Preview: Ford 2000

Preview: Ford 8N-8NAN

Preview: Ford LGT 14D

Preview: Ford 601 series

Ford 601 series

Preview: Ford fordson dexta

Ford fordson dexta

Ford 5000 super major

Ford fordson power major

Ford new performance super major